Auto Parts Search
2009 Toyota RAV4 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Toyota REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Toyota RAV4 AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2009 Toyota RAV4 3.5 V6 GAS
- Place vehicle in neutral.
- Release parking brake.
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove two bolts and two adjusting washers and disconnect driveline with center bearing shaft.Do not exert excessive force on universal joint when removing driveline assembly.
- Place reference mark on driveline and differential flange. Paint is recommended for match marks. Never damage rear driveline shaft differential flange.
- Remove bolts, nuts, and washers f...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota RAV4 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Toyota RAV4 AUTOMOBILES
Reset Procedures
Vehicle: 2009 Toyota RAV4 Limited 3.5 V6 GAS
This warning lamp will illuminate when tire pressure falls below a specified psi. When the warning lamp illuminates, check the air...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota RAV4 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Toyota RAV4 AUTOMOBILES
Starter, Replace
Vehicle: 2009 Toyota RAV4 Sport 2.5 L4 GAS
- Disconnect cable from battery ground terminal.
- Disconnect cable from positive battery terminal.
- Remove radiator support opening cover.
- Remove bolt and loosen nut.
- Detach two wire harness clamps.
- Detach hook of battery clamp from front battery bracket, and then remove battery clamp.
- Remove battery insulator.
- Remove battery.
- Remove battery tray.
- Detach two wire harness clamps from front battery bracket.
- Remove four bolts and front battery bracket.
- Remove two bolts and battery bracket reinforcement.
- Disconnect starter ...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota RAV4 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 Toyota RAV4 AUTOMOBILES
Cabin Air Filter Service -> Toyota -> 2006-09 RAV4
Vehicle: 2009 Toyota RAV4 3.5 V6 GAS
The cabin air filter should be replaced every 36 months or 30,000 miles. The filter should be replaced more often if air flow is less than normal.
- Open the glove compartment, then slide off damper rod, Fig. .
- Push inward on each side of glove compartment to disconnect claws, Fig. .
- Remove the cabin air filter cover, Fig. .
- Remove th...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota RAV4 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Toyota RAV4 AUTOMOBILES
Toyota -> Low Oil Level Warning Indicator ->
Vehicle: 2009 Toyota RAV4 Sport 3.5 V6 GAS
This lamp lights to indicate that the engine oil level is below a specified level. The lamp will be illuminated during engine start-up. If...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota RAV4 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Toyota RAV4 AUTOMOBILES
Radiator, Replace
Vehicle: 2009 Toyota RAV4 2.5 L4 GAS
- Disconnect battery ground cable.
- Remove six screws and A/C air intake duct.
- Remove No.1 engine under cover.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- On models with automatic transaxle, disconnect a/t cooler hoses. Some oil will leak, catch it in a suitable container. Plug pipe to prevent oil from escaping.
- On all models, disconnect ...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota RAV4 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Toyota RAV4 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Toyota RAV4 Limited 3.5 V6 GAS
- Remove radiator reservoir tank assembly, then lay aside.
- Remove clips from engine cover.
- Remove bolts from righthand front suspension member reinforcement.
- Rotate or lift belt tensioner arm counterclockwise, using a suitable tool t...
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota RAV4 SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Toyota RAV4 AUTOMOBILES
OEM TSB listings for most 2009 Toyota RAV4 cars and light trucks sold in the U.S. from 1985+.
Document: Intermittent No Crank/No Start Vehicle: 2009 Toyota RAV4 3.5 V6 GAS Symptoms: |
Document: XM SATELLITE RADIO INOPERATIVE UNTIL IGNITION KEY IS CYCLED Vehicle: 2009 Toyota RAV4 3.5 V6 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota RAV4 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Toyota RAV4 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Toyota RAV4 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Toyota RAV4 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Toyota RAV4 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Toyota RAV4 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Toyota RAV4 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Toyota RAV4 vehicle. |
Access the Complete guide! |