Auto Parts Search
2008 Toyota Yaris CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Toyota REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2008 Toyota Yaris AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2008 Toyota Yaris CE 1.5 L4 GAS
- Raise and support vehicle.
- Remove engine under cover.
- Drain transmission fluid into a suitable container.
- Remove wheel lug nuts.
- Remove front axle hub nut.
- Remove bolt and separate speed sensor and flexible hose.
- Remove nut and separate stabilizer link from shock absorber.
- Remove cotter pin and castle nut from tie rod.
- Make sure upper ends of threaded section of tie rod end and SST (spacer B) are aligned.
- Separate tie rod end from front axle assembly.
- Remove clip and castle nut from lower control arm.
- Separate front lower contr...
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2008 Toyota Yaris AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing DTCs (Diagnostic Trouble Codes) -> Diagnostic Trouble Code Identification -> Using Scan Tool -> Using TPMS Warning Lamp
Vehicle: 2008 Toyota Yaris CE 1.5 L4 GAS
Accessing Diagnostic Trouble Codes
Using TPMS Warning Lamp
- Place the ignition switch in the Off position.
- Using Toyota SST or other suitable jumper, connect terminals TC and CG of DLC3. The DLC3 is located under the left side of the instrument panel, Fig. .
- Place the ignition switch in the On position.
- Read and note DTCs indicated by flashes of the TPMS warning lamp, Fig. .
- If the TPMS warning lamp blinks in .25 second intervals, a normal condition is indicated, Fig. .
- If the TPMS warning lamp blinks in .5 second intervals followed by a 1.5 second pause, then additional .5 second i...
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2008 Toyota Yaris AUTOMOBILES
Alternator, Replace
Vehicle: 2008 Toyota Yaris LE 1.5 L4 GAS
- Disconnect battery cables.
- Raise vehicle on suitable lift.
- Remove bolts securing engine under cover subassembly.
- Loosen alternator upper bracket bolt and lower mounting bolt.
- Push in an alternator assembly and remove drive belt.
- Remove alternator wiring harness clamp.
- Open B+ terminal cap and remove alternator B+ terminal nut.
- Dis...
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2008 Toyota Yaris AUTOMOBILES
Cabin Air Filter Service -> Toyota -> 2007-09 Yaris
Vehicle: 2008 Toyota Yaris RS 1.5 L4 GAS
The cabin air filter should be replaced every 36 months or 30,000 miles. The filter should be replaced more often if air flow is less than normal.
- Open the glove compartment door, then disconnect the damper rod from the glove compartment, Fig. .
- Push inward at both sides of the glove compartment, then pull the glove compartment downward.
- Through the glove compartment opening, release two retaining clips securing filter cover to A/C unit and remove the filter cover, Fig. .
- Remove the cabin air filter element fro...
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2008 Toyota Yaris AUTOMOBILES
Toyota -> Automatic Transmission Overdrive Lamp ->
Vehicle: 2008 Toyota Yaris S 1.5 L4 GAS
The "OD Off" lamp will be illuminated when the ignition switch is in the On position and the Overdrive (OD) switch is in the Off position. When the OD switch is placed in the On position, the "OD Off" lamp should go out. If the lamp flashes when the switch is placed in the On position, a fault has been detected by the electronic control system. After diagnosis and repair are c...
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2008 Toyota Yaris AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2008 Toyota Yaris 1.5 L4 GAS
Inlet
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at heater core.
- Remove hose from heater core.
- Reposition hose clamp at water outlet.
- Remove hose from water outlet.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp a...
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2008 Toyota Yaris AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2008 Toyota Yaris RS 1.5 L4 GAS
- Remove bolts from righthand engine cover assembly, then remove cover.
- Loosen bolts from upper and lower alternator mounting bracket.
- Rotate or lift belt tensioner arm counterclockwise, using a suitable tool to relieve tension from...
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2008 Toyota Yaris AUTOMOBILES
Component location diagrams for most 2008 Toyota Yaris cars and light trucks sold in the U.S. from 1990+.
Instrument Panel Diagram for 2008 Toyota Yaris S 1.5 L4 GAS Components on diagram: |
Body Components and Connectors Diagram for 2008 Toyota Yaris S 1.5 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2008 Toyota Yaris AUTOMOBILES
OEM drawn wiring diagrams for most 2008 Toyota Yaris cars and light trucks sold in the U.S.
2008 Toyota Yaris S 1.5 L4 GAS Wiring Diagram Components on diagram: |
2008 Toyota Yaris 1.5 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2008 Toyota Yaris AUTOMOBILES
OEM TSB listings for most 2008 Toyota Yaris cars and light trucks sold in the U.S. from 1985+.
Document: Rattle Noise From Automatic Transmission Control Cable Assembly In Reverse Vehicle: 2008 Toyota Yaris S 1.5 L4 GAS Symptoms: |
Document: HVAC Odor Vehicle: 2008 Toyota Yaris S 1.5 L4 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2008 Toyota Yaris AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2008 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2008 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2008 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2008 Toyota Yaris cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2008 Toyota Yaris SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2008 Toyota Yaris vehicle. |
Access the Complete guide! |