Auto Parts Search


      Over 40 million used auto parts online. Shop online for auto and truck parts and save up to 75%

Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!
Help me findSearch
Get Full Access Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2006 Chevrolet Cobalt car and truck repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up & drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix your 2006 Chevrolet Cobalt automobile. Try the Automotix DIY solution today!
DIY REPAIR SAMPLES > CONTINUE EXPLORING >

We have info for following modifications of 2006 Chevrolet Cobalt

  • 2006 Chevrolet Cobalt LTZ 2.2 L4 GAS, CC:2189, CID:134, Fuel Injection, Aspiration:134, Engine VIN:, Desg:F
  • 2006 Chevrolet Cobalt LS 2.2 L4 GAS, CC:2189, CID:134, Fuel Injection, Aspiration:134, Engine VIN:, Desg:F
  • 2006 Chevrolet Cobalt LT 2.2 L4 GAS, CC:2189, CID:134, Fuel Injection, Aspiration:134, Engine VIN:, Desg:F
  • 2006 Chevrolet Cobalt SS 2.0 L4 GAS, CID:122, Fuel Injection, Aspiration:122, Engine VIN:, Desg:P
  • 2006 Chevrolet Cobalt SS 2.4 L4 GAS, CID:145, Fuel Injection, Aspiration:145, Engine VIN:, Desg:B

BRAKE SERVICE PROCEDURES FOR 2006 Chevrolet Cobalt AUTOMOBILES

Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2006 Chevrolet Cobalt cars and light trucks from 1990+.

Hydraulic Brake Systems -> Brake System Bleed -> Bleed Sequence -> Manual -> Pressure
Vehicle: 2006 Chevrolet Cobalt LT 2.2 L4 GAS

Brake fluid is corrosive to painted surfaces. Care must be taken not to allow brake fluid to come in contact with painted surfaces on vehicle.

When bleeding the brake system, always bleed righthand rear wheel circuit first, followed by the lefthand front, lefthand rear and, finally, righthand front.

Manual

Pressure bleeding is recommended for all hydraulic systems. However, if a pressure bleeder is unavailable, use the following procedure. Brake fluid damages painted surfaces. Immediately clean any spilled fluid.

  • Remove vacuum reserve by pumping brakes several times with engine o...

CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Cobalt BRAKE SERVICE PROCEDURES

BRAKE SERVICE PROCEDURES FOR 2006 Chevrolet Cobalt AUTOMOBILES

Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2006 Chevrolet Cobalt cars and light trucks from 1990+.

Power Brake Units -> Adjustments -> AC-Delco Tandem Diaphragm Type -> Air Method -> Brake Pedal -> Gauge Method -> Pushrod -> Toyota/GM Single Diaphragm Type
Vehicle: 2006 Chevrolet Cobalt LT 2.2 L4 GAS

Brake Pedal

Toyota/GM Single Diaphragm Type
  • With engine running and brake pedal in rest position, measure distance between face of pedal and floor mat.
  • Distance should be 5.850-6.244 inches.
  • If distance is not as specified, adjust pedal height as follows:
    • Remove lefthand lower instrument panel trim section and air duct.
    • Loosen stop lamp switch sufficiently to access pedal adjustment.
    • Loosen locknut and rotate pedal pushrod as required to obtain specified pedal height. Tighten locknut.
    • Adjust brake lamp switch position so plunger lightly contacts pedal stopper and brake lamps are off when pe...

CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Cobalt BRAKE SERVICE PROCEDURES

BRAKE SERVICE PROCEDURES FOR 2006 Chevrolet Cobalt AUTOMOBILES

Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2006 Chevrolet Cobalt cars and light trucks from 1990+.

Hydraulic Brake Systems -> Troubleshooting -> Master Cylinder Internal Fluid Leakage Check -> Road Test
Vehicle: 2006 Chevrolet Cobalt LT 2.2 L4 GAS

When troubleshooting the hydraulic brake system, perform the following inspections.

Master Cylinder Internal Fluid Leakage Check

Start engine and depress the brake pedal. If the pedal gradually falls under constant pressure, the hydraulic system may be leaking. Raise the vehicle on a lift and inspect all tubing lines and backing plates for signs of leakage. It may be required to lift or remove the carpeting or floor mats to inspect for boost...

CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Cobalt BRAKE SERVICE PROCEDURES

BRAKE SERVICE PROCEDURES FOR 2006 Chevrolet Cobalt AUTOMOBILES

Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2006 Chevrolet Cobalt cars and light trucks from 1990+.

Disc Brakes -> Saturn/GM Single Piston -> Caliper Service -> Assemble -> AURA, Cobalt, G5, ION, Solstice & SKY -> Disassemble -> Front -> Inspection -> L-Series -> Rear -> Replacement
Vehicle: 2006 Chevrolet Cobalt LT 2.2 L4 GAS

AURA, Cobalt, G5, ION, Solstice & SKY

Replacement
  • Raise and support vehicle, then remove tire and wheel assemblies.
  • Install and tighten two wheel nuts opposite to retain rotor to hub.
  • Tighten suitable C-clamp to compress piston into caliper bore.
  • Remove mounting bolt and brake hose from caliper, Fig. .
  • Remove and discard copper brake hose gaskets.
  • Cap opening in brake caliper and brake hose.
  • Remove guide pin bolts, caliper and bracket.
  • Reverse procedure to install.
Disassemble
  • Remove caliper piston from bore using compressed air through fluid inlet hole.
  • Remove retaining ring to dust boot o...

CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Cobalt BRAKE SERVICE PROCEDURES

BRAKE SERVICE PROCEDURES FOR 2006 Chevrolet Cobalt AUTOMOBILES

Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2006 Chevrolet Cobalt cars and light trucks from 1990+.

Disc Brakes -> Saturn/GM Single Piston -> Disc Brake Specifications -> Caliper Specifications
Vehicle: 2006 Chevrolet Cobalt SS 2.4 L4 GAS

[[table data]]

CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Cobalt BRAKE SERVICE PROCEDURES

BRAKE SERVICE PROCEDURES FOR 2006 Chevrolet Cobalt AUTOMOBILES

Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2006 Chevrolet Cobalt cars and light trucks from 1990+.

Power Brake Units -> Power Brake Unit Service
Vehicle: 2006 Chevrolet Cobalt SS 2.4 L4 GAS

Hydro-boost brake boosters are...

CLICK HERE TO GET FULL ACCESS TO 2006 Chevrolet Cobalt BRAKE SERVICE PROCEDURES

Shop online for auto body parts, engines, wheels, lights...

Click here to view more details about 2007 Chevrolet Cobalt Cigarette Lighter2007 Chevrolet Cobalt Cigarette Lighter, With wire terminal; A high quality cigarette lighter; Backed by 1-year, unlimited-mileage warranty..

Source: Auto Body Parts Store

$6.39

Click here to view more details2006 Chevrolet Cobalt Wiper Blade, Front, Driver Or Passenger Side, Rear, 17 in. length; Includes easy to follow installation instructions; This wiper blade provides improved wiping capabilities in rain and freezing weather, long lasting durability, an easy to service design using a rubber insert that requires no special tools or high cost items to replace, and a clean appearance from inside the vehicle with the wiper profile neatly conforming to the base of the windshield; With 1-year limited Martins warranty..

Source: Auto Body Parts Store

$4.13

Click here to view more details about 2006 Chevrolet Cobalt 16" x 6" Alloy Wheel2006 Chevrolet Cobalt 16" x 6" Alloy Wheel, Alloy Wheel; 16 X 6; 5 Spokes; 4 Lug; 100MM BP; Machined With Silver Vents, , .

Source: Wheels / Rims, Mirrors & Lights Store

$103.45

Click here to view more details1971 International 1310 V8, 5 L, 304 CID Rebuilt Engine, Scout appl. Comes with oil pump kit only., Warranty: 3-Year/100,000 Mile, .

Source: Rebuilt Engines Store

$2,252.00

Click here to view more details2005 Chevrolet Cobalt Used A/C Compressor, 2.0L (RED LINE PKG, OPT LSJ), 621198, Very Good.

Source: Used Auto Parts Store

$103.00

Click here to view more details2005 Chevrolet Cobalt Used Air Flow Meter/Sensor, 1.2, AUTO, FWD, Very Good.

Source: Used Auto Parts Store

$77.00
More parts
Help me findSearch
Auto Repair Quick Search
Help me find
Search DIY repair manuals by VIN...
Vehicle Identification Number is a unique serial number used by the automotive industry to identify individual motor vehicles

Find out what info we have for your vehicle

Get the Complete Technical Service Bulletins!
Get the Complete Technical Service Bulletins!Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Chevrolet Cobalt vehicle.
Access the Complete guide!
Need To Fix Your Car or Truck?
Save Money With Free Car Insurance Quote
FREE car insurance quote
Enter Zip Code:
GOT A WEBSITE?Make money with Automotix

Make money with Automotix Partner Program.

Learn more

Auto Repair Quick Search
Help me find