Auto Parts Search
1999 Ford E-350 Econoline CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Ford REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 1999 Ford E-350 Econoline car and truck
repair procedures including Ford engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Ford E-350 Econoline automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 1999 Ford E-350 Econoline AUTOMOBILES
General Service Domestic Vehicles -> 1998-2000 -> Pressure Gauge Indication
Vehicle: 1999 Ford E-350 Econoline Super 5.4 V8 GAS
Due to the different types of models and systems, the following typical pressure gauge indications should be used as a guide only as shown in Fig. . Refer to the "Performance Tests" or "System Pressure Check" for the particular model being tested. When indications other than normal are encountered, these typical indication charts will assist in diagnosing the refrigerant system. It should be noted that pressures may vary slightly above or below due to changes in ambient temperature and relative humidity.
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Ford E-350 Econoline AUTOMOBILES
Anti-lock Brakes -> E-Series, Excursion, Expedition, Explorer, F-150/250LD, F-Super Duty Mountaineer, Navigator & Ranger (4WABS) -> Diagnosis & Testing -> 1997 -> 1997 E-Series -> 1997 Expedition -> 1997 Explorer -> 1997 F-150 -> 1997 Mountaineer -> 1997 Navigator -> 1997 Ranger -> 1997F-250LD -> 1998 E-Series -> 1998 Expedition -> 1998 Explorer -> 1998 F-150 -> 1998 F-250LD -> 1998 Mountaineer -> 1998 Navigator -> 1998 Ranger -> 1999 E-Series -> 1999 Expedition -> 1999 Explorer -> 1999 F-150 -> 1999 F-250LD -> 1999 Mountaineer -> 1999 Navigator -> 1999 Ranger -> 2000 E-Series -> 2000 Expedition -> 2000 Explorer -> 2000 F-150 -> 2000 Mountaineer -> 2000 Navigator -> 2000 Ranger -> 2001 E-Series -> 2001 Expedition -> 2001 Explorer -> 2001 F-150 -> 2001 Mountaineer -> 2001 Navigator -> 2001 Ranger -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Tests -> Diagnostic Trouble Code Interpretation -> Drive Cycle Tests -> Excursion -> Explorer & Mountaineer -> F-Super Duty Series -> F-Super Duty Series & Excursion -> Intermittent Diagnosis -> Quick Check -> Ranger -> System Pre-Check -> Wiring Diagrams
Vehicle: 1999 Ford E-350 Econoline 5.4 V8 BI-FUEL
Accessing Diagnostic Trouble Codes
- Connect New Generation STAR (NGS) Tester to Data Link Connector (DLC) located beneath instrument panel.
- Select vehicle to be tested from NGS menu.
- If NGS does not communicate with vehicle, proceed as follows:
- Ensure program card is properly installed.
- Inspect connections to vehicle.
- Ensure ignition is in On position.
- If NGS still does not communicate with vehicle, refer to NGS Tester manual.
- Follow NGS Tester instructions to retrieve DTC's.
Diagnostic Trouble Code Interpretation
Refer to Figs. through for diagnostic trouble code interpretation.
Wiri...
[[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]] [[table data]]CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1999 Ford E-350 Econoline AUTOMOBILES
Ford Motor Co. Light Trucks, SUVs & Vans -> Fuel Filter Scheduled Maintenance -> 1995-06 Econoline w/Diesel Engine -> Normal Service -> Severe Service
Vehicle: 1999 Ford E-350 Econoline 7.3 V8 DIESEL
Normal Service
Replace e...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1999 Ford E-350 Econoline AUTOMOBILES
DRIVESHAFT, Replace -> One Piece Driveshaft -> Three Piece Driveshaft -> Two Piece Driveshaft
Vehicle: 1999 Ford E-350 Econoline 5.4 V8 CNG
One Piece Driveshaft
- Raise and support vehicle.
- To maintain driveline balance, index-mark driveshaft flange yoke and pinion flange.
- Index-mark driveshaft yoke and transmission tailshaft. Do not allow output shaft to turn.
- Remove four bolts.
- Disconnect driveshaft flange yoke from pinion flange, using a suitable tool as shown. Driveshaft flange yoke fits tightly on pinion flange pilot. Never hammer on driveshaft or any of its components to disconnect yoke from flange. Pry only in area shown, with a suitable tool, to disconnect yoke from flange.
- Lower driveshaft and slide it off outp...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1999 Ford E-350 Econoline AUTOMOBILES
Alternator, Replace
Vehicle: 1999 Ford E-350 Econoline 5.4 V8 CNG
- Disconnect battery ground cable.
- Disconnect electrical connector from alternator.
- Remove alternator drive belt.
- Remove alternator...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1999 Ford E-350 Econoline AUTOMOBILES
Ford Motor Co. Trucks -> Low Oil Level Warning Indicator ->
Vehicle: 1999 Ford E-350 Econoline 5.4 V8 BI-FUEL
This system is used to indicate a low engine oil level condition. The lamp should light during engine starting. If oil level is sufficient, the lamp should go off when engine is operating. If oil level is low the...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1999 Ford E-350 Econoline AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 1999 Ford E-350 Econoline 5.4 V8 BI-FUEL
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from water inlet.
- Remove radiator outlet hose from water inlet and from vehicle.
- Reverse procedur...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1999 Ford E-350 Econoline AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1999 Ford E-350 Econoline Super 5.4 V8 GAS
- Rotate drive belt tensioner counterclockwise, using a 1/2 square hole in drive belt tensioner pull...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1999 Ford E-350 Econoline AUTOMOBILES
Component location diagrams for most 1999 Ford E-350 Econoline cars and light trucks sold in the U.S. from 1990+.
 Engine Components Diagram for 1999 Ford E-350 Econoline 5.4 V8 GASComponents on diagram: |
 Battery & Alternator Diagram for 1999 Ford E-350 Econoline 5.4 V8 BI-FUELComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1999 Ford E-350 Econoline AUTOMOBILES
OEM drawn wiring diagrams for most 1999 Ford E-350 Econoline cars and light trucks sold in the U.S.
 1999 Ford E-350 Econoline Super 5.4 V8 GAS Wiring DiagramComponents on diagram: |
 1999 Ford E-350 Econoline Super Wagon 5.4 V8 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1999 Ford E-350 Econoline AUTOMOBILES
OEM TSB listings for most 1999 Ford E-350 Econoline cars and light trucks sold in the U.S. from 1985+.
|
Document: SAFETY RECALL - SPEED CONTROL SYSTEM MODIFICATION Vehicle: 1999 Ford E-350 Econoline 5.4 V8 GAS Auto Systems: |
|
Document: RECALL - CERTAIN 1992-2003 MODEL YEAR CARS AND TRUCKS - FUSED JUMPER HARNESS REPLACEMENT FOR VEHICLES SERVICED WITH AN INCOMPATIBLE FUSED JUMPER HARNESS Vehicle: 1999 Ford E-350 Econoline 5.4 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1999 Ford E-350 Econoline AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1999 Ford E-350 Econoline cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1999 Ford E-350 Econoline cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1999 Ford E-350 Econoline cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1999 Ford E-350 Econoline cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-350 Econoline SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 1999 Ford E-350 Econoline vehicle.
|
| Access the Complete guide! |
