Auto Parts Search
1994 MERCEDES-BENZ C220 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT MERCEDES-BENZ REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
Mercedes-Benz -> Component Replacement & Adjustment -> CIRCULATING PUMP, REPLACE
Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS
- Disconnect battery ground cable.
- Drain engine coolant.
- Disconnect and cap water hoses.
- Disconnect circulating pump electrical connector.
- Remove three attaching screws, then the circulating pump from bracket...
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
Anti-lock Brakes -> System Service -> ABS Control Unit -> Brake System Bleed -> C220 & C280 -> C220, C280, E300, E320, E420, E500, 190E, 300CE, D, E, SL & TE, 400E, 500E & SL -> Component Replacement -> E300, E320, E420, E500, 190E, 300CE, D, E & TE, 400E & 500E -> E300, E320, E420, E500, 190E, 300CE, D, E, SL & TE, 400E, 500E & SL -> E420, SL320, S320, S350, S420, S500, S600, 300SD, 400SE, 500SEC& SEL, 600SEC & SEL & 1993 300SE -> Front Wheel Speed Sensor -> Rear Wheel Speed Sensor -> S320, S350, S420, S500, S600, SL320, SL500, SL600, 300SD & SL, 400SE, 500SEC, SEL & SL, 600SEC, SEL & SL & 1993 300SE
Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS
Refer to Figs. through when servicing system components.
Brake System Bleed
On 400SE, 500SEL and 600SEL models, master cylinder brake switch over valve must be electrically activated to bleed additional pressure chamber.
- With ignition in Off position, empty pressure reservoir at bleeder valve SP, then close valve, Fig. .
- Connect suitable pressure bleeder.
- Bleed brakes at each wheel, allow about 1 pint (.5 liter) of brake fluid to flow.
- Start engine.
- Open SP bleeder valve until brake fluid flows clear, with no bubbles.
- Close bleeder valve, charging pump will run about 30 seconds.
- ...
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
Mercedes-Benz -> Fuel Filter Replacement -> Except 2003-06 E320 & E500 Sedans Less 4 Matic & 2004-06 E Series w/Gasoline Engines -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS
Fuel System Pressure Relief
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental fuel spray.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while it relearns its adaptive strategy.
- Ensure t...
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS
- Raise vehicle and support.
- Unscrew exhaust shielding plate.
- On models with 4MATIC, unscrew exhaust shielding plate.
- Lift transmission and support.
- Unscrew cross bridge.
- Unscrew hex, head screws and hex nut and remove rear engine carrier with engine mount.
- On all models, loosen propeller shaft clamping nut for approx. two turns without sliding back rubber sleeve (sliding along).
- Remove front propeller shaft from transmission. Flexible coupling remains on propeller shaft.
- Remove front propeller shaft from transfer case.
- Prior to sliding back propeller shaft, loosen vulcanized fitted ...
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
Alternator, Replace
Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS
- Disconnect battery ground cable from battery.
- Remove drive belt.
- Remove lower engine compartment paneling.
- Remove bottom parts of soundproofing.
- Remove protective cap from alternator connections.
- Disconnect electrical connections from alternator...
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
Cabin Air Filter Service -> Mercedes-Benz -> 1994-2001 C Class & 1998-2001 CLK & SLK
Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the instrument panel lower righthand cover retainers, then the cover, Fig. .
- Disengage the cabin filter cover retainers, then remove the cover.
- Remove the cabin air filter element from the filter housi...
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
Mercedes-Benz -> Air Bag Off Lamp ->
Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS
The Air Bag Off should illuminate for 6 seconds when the ignition switch is placed in the On position. The lamp will illuminate when the specified child safety seat has been properly installed on the passenger front seat, indicating that the front passenger ...
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS
Inlet
- Drain coolant into a suitable container.
- Reposition clamp on heat exchanger feed pipe and remove hose.
- Reposition clamp on thermostat housing and remove hose.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Drain coolant into a suitable container.
- Reposition clamp on heat exchanger return pip...
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS
- Remove viscous fan coupling and fan shroud.
- Loosen tensioning arm and pulley co...
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
Component location diagrams for most 1994 MERCEDES-BENZ C220 cars and light trucks sold in the U.S. from 1990+.
Luggage Compartment Component Relays & Control Modules Diagram for 1994 MERCEDES-BENZ C220 2.2 L4 GAS Components on diagram: |
Luggage Compartment Ground Locations Diagram for 1994 MERCEDES-BENZ C220 2.2 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
OEM drawn wiring diagrams for most 1994 MERCEDES-BENZ C220 cars and light trucks sold in the U.S.
1994 MERCEDES-BENZ C220 2.2 L4 GAS Wiring Diagram Components on diagram: |
1994 MERCEDES-BENZ C220 2.2 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
OEM TSB listings for most 1994 MERCEDES-BENZ C220 cars and light trucks sold in the U.S. from 1985+.
Document: Introduction of Improved Single-Component Windshield/Window Bonding System Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS Auto Systems: |
Document: Headlamp Color and/or Brightness Difference When Changing Xenon Bulb Vehicle: 1994 MERCEDES-BENZ C220 2.2 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1994 MERCEDES-BENZ C220 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1994 MERCEDES-BENZ C220 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1994 MERCEDES-BENZ C220 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1994 MERCEDES-BENZ C220 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1994 MERCEDES-BENZ C220 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1994 MERCEDES-BENZ C220 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1994 MERCEDES-BENZ C220 vehicle. |
Access the Complete guide! |