Auto Parts Search
We have info for following modifications of 1992 Mitsubishi Galant
- 1992 Mitsubishi Galant 2.0 L4 GAS, CC:1997, CID:122, Fuel Injection, Aspiration:122, Engine VIN:, Desg:V
- 1992 Mitsubishi Galant GS 2.0 L4 GAS, CC:1997, CID:122, Fuel Injection, Aspiration:122, Engine VIN:, Desg:R
- 1992 Mitsubishi Galant LS 2.0 L4 GAS, CC:1997, CID:122, Fuel Injection, Aspiration:122, Engine VIN:, Desg:V
- 1992 Mitsubishi Galant GSX 2.0 L4 GAS, CC:1997, CID:122, Fuel Injection, Aspiration:122, Engine VIN:, Desg:R
- 1992 Mitsubishi Galant GSR 2.0 L4 GAS, CC:1997, CID:122, Fuel Injection, Aspiration:122, Engine VIN:, Desg:R
- 1992 Mitsubishi Galant VR-4 2.0 L4 GAS, CC:1997, CID:122, Fuel Injection, Aspiration:122, Engine VIN:, Desg:U
BRAKE SERVICE PROCEDURES FOR 1992 Mitsubishi Galant AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Mitsubishi Galant cars and light trucks from 1990+.
MITSUBISHI, ANTI-LOCK BRAKES -> SYSTEM DIAGNOSIS -> Diagnostic Tests -> DIAMANTE -> ECLIPSE, EXPO, GALANT & 3000GT -> Erasing trouble codes -> MONTERO -> PICKUP -> SIGMA -> Using ABS Warning Light -> Using Multi-Use Tester (MUT) -> Using Voltmeter
Vehicle: 1992 Mitsubishi Galant GS 2.0 L4 GAS
On models with airbags, serious injury can result from unintended airbag deployment.
To disarm the airbag, disconnect, tape and isolate the battery ground cable. Wait at least 30 seconds before any further work is attempted. The Supplemental Restraint System (SRS) is designed to retain sufficient voltage to deploy the airbag for a short time after the battery has been disconnected. Serious injury may result from unintended airbag deployment if service is attempted immediately after battery ground cable is disconnected.
After service is completed, ensure no one is inside of v...
[[table data]] [[table data]] [[table data]] [[table data]]CLICK HERE TO GET FULL ACCESS TO 1992 Mitsubishi Galant BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Mitsubishi Galant AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Mitsubishi Galant cars and light trucks from 1990+.
MITSUBISHI, HYDRAULIC BRAKE SYSTEM -> HYDRAULIC SYSTEM BLEEDING
Vehicle: 1992 Mitsubishi Galant GSX 2.0 L4 GAS
Bleeding the hydraulic brake system is necessary if air has entered the system. A few causes for this condition are low fluid level, a hydraulic fluid leak, a hydraulic line is opened, or replacement of a hydraulic system component. Symptoms can be noted by an improper or loss of brake operation, and/or a low or spongy brake pedal.
- Ensure master cylinder reservoir is full. Add suitable brake fluid as needed, and securely reinstall the master cylinder cap.
- Raise and support vehicle.
- Position a drain pan under the wheel being bled.
- Have an assistant depress the brake pedal w...
CLICK HERE TO GET FULL ACCESS TO 1992 Mitsubishi Galant BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Mitsubishi Galant AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Mitsubishi Galant cars and light trucks from 1990+.
MITSUBISHI, HYDRAULIC BRAKE SYSTEM -> MASTER CYLINDER BLEED
Vehicle: 1992 Mitsubishi Galant 2.0 L4 GAS
- If master cylinder has been replaced or overhauled and reservoir is empty, proceed as follows:
- Disconnect brake lines from master cylinder.
- Depress pedal slowly...
CLICK HERE TO GET FULL ACCESS TO 1992 Mitsubishi Galant BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Mitsubishi Galant AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Mitsubishi Galant cars and light trucks from 1990+.
MITSUBISHI, DISC BRAKES -> Eclipse, Expo, Galant & Sigma -> REAR BRAKES -> BRAKE PADS, REPLACE -> CALIPER INSTALLATION -> CALIPER REMOVAL -> CALIPER SERVICE -> Eclipse & Galant -> Expo & Sigma -> PARKING BRAKE ADJUSTMENT -> PARKING BRAKE OVERHAUL -> ROTOR, REPLACE
Vehicle: 1992 Mitsubishi Galant 2.0 L4 GAS
BRAKE PADS, REPLACE
- Raise and support vehicle, then remove wheel.
- Remove parking brake cable.
- Remove lower lockpin, Figs. through , and lift caliper body upward, then support caliper with wire. Lockpin is coated with special grease. Use caution not to remove grease and ensure no dirt adheres to pin.
- Remove outer shim and pad assembly from caliper support.
- Remove pad clips.
- Measure hub torque with pad removed to aid in measuring brake drag torque after pad installation, Fig. .
- Press piston into cylinder using a suitable tool. Ensure stopper grooves in rear of piston are in the vertical pos...
CLICK HERE TO GET FULL ACCESS TO 1992 Mitsubishi Galant BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Mitsubishi Galant AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Mitsubishi Galant cars and light trucks from 1990+.
MITSUBISHI, ANTI-LOCK BRAKES -> TROUBLESHOOTING -> EXCEPT DIAMANTE, PICKUP, & SIGMA -> PICKUP -> SIGMA
Vehicle: 1992 Mitsubishi Galant VR-4 2.0 L4 GAS
EXCEPT DIAMANTE, PICKUP, & SIGMA
Problems related to the Anti-Lock Brake System (ABS) can be classified into two general categories; problems in the electrical system and those in the hydraulic system.
For problems in the electrical system, the self-diagnostic function is built into the Electronic Control Unit (ECU) causing the ABS warning lamp to illuminate as a warning to the driver. In this instance, checks can be made by using the multi use tester and...
CLICK HERE TO GET FULL ACCESS TO 1992 Mitsubishi Galant BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Mitsubishi Galant AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Mitsubishi Galant cars and light trucks from 1990+.
MITSUBISHI, ANTI-LOCK BRAKES -> DESCRIPTION
Vehicle: 1992 Mitsubishi Galant GSR 2.0 L4 GAS
The Anti-Lock Braking System (ABS) prevents wheels from locking up when braking, regardless of the surface conditions. This allows the vehicle to stop in a shorter distance, and allows the driver to maintain directional control of the vehicle during heavy braking.
Du...
CLICK HERE TO GET FULL ACCESS TO 1992 Mitsubishi Galant BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1992 Mitsubishi Galant vehicle. |
Access the Complete guide! |