Auto Parts Search
We have info for following modifications of 1992 Hyundai Excel
- 1992 Hyundai Excel GL 1.5 L4 GAS, CC:1468, Fuel Injection, Engine VIN:, Desg:J
- 1992 Hyundai Excel 1.5 L4 GAS, CC:1468, Fuel Injection, Engine VIN:, Desg:J
- 1992 Hyundai Excel L 1.5 L4 GAS, CC:1468, Fuel Injection, Engine VIN:, Desg:J
- 1992 Hyundai Excel CXL 1.5 L4 GAS, CC:1468, Fuel Injection, Engine VIN:, Desg:J
- 1992 Hyundai Excel GS 1.5 L4 GAS, CC:1468, Fuel Injection, Engine VIN:, Desg:J
BRAKE SERVICE PROCEDURES FOR 1992 Hyundai Excel AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Hyundai Excel cars and light trucks from 1990+.
HYUNDAI, ANTI-LOCK BRAKES -> DIAGNOSIS & TESTING -> BASIC DIAGNOSIS -> DESCRIPTION -> DIAGNOSIS USING SELF-DIAGNOSTIC MODE -> INITIAL CHECK -> SYSTEM CIRCUIT INSPECTION
Vehicle: 1992 Hyundai Excel 1.5 L4 GAS
DESCRIPTION
If a malfunction occurs, the diagnostic system will identify the problem and the ECU will store the codes. At the same time, the system informs the driver of a malfunction with the ABS warning lamp.
INITIAL CHECK
Start engine and drive at a speed of 3-6 mph, then verify that the modulator is operating by listening for motor pump hum and solenoid clicking for 1 or 2 seconds. Procedure should be performed within first three minutes after start up. Solenoid valve and motor pump cycling takes place between 3 and 6 mph, as long as brake is not applied.
BASIC DIAGNOSIS
- Chec...
CLICK HERE TO GET FULL ACCESS TO 1992 Hyundai Excel BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Hyundai Excel AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Hyundai Excel cars and light trucks from 1990+.
HYUNDAI, POWER BRAKE UNITS -> POWER BRAKE BOOSTER REPLACEMENT
Vehicle: 1992 Hyundai Excel GL 1.5 L4 GAS
- Remove master cylinder, refer to "Master Cylinder, Replace" in "Hydraulic Brake System".
- Disconnect vacuum hose.
- From inside vehicle, se...
CLICK HERE TO GET FULL ACCESS TO 1992 Hyundai Excel BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Hyundai Excel AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Hyundai Excel cars and light trucks from 1990+.
HYUNDAI, HYDRAULIC BRAKE SYSTEM -> HYDRAULIC BRAKE SPECIFICATIONS
Vehicle: 1992 Hyundai Excel 1.5 L4 GAS
CLICK HERE TO GET FULL ACCESS TO 1992 Hyundai Excel BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Hyundai Excel AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Hyundai Excel cars and light trucks from 1990+.
HYUNDAI -> Disc Brakes -> CALIPER SERVICE -> Assembly -> Disassembly -> ELANTRA & SONATA -> EXCEL & SCOUPE -> FRONT -> Installation -> REAR -> Removal
Vehicle: 1992 Hyundai Excel GS 1.5 L4 GAS
EXCEL & SCOUPE
Removal
- Remove brake pads as described previously.
- Disconnect and cap brake line(s).
- Remove caliper attaching bolts and caliper assembly from steering knuckle.
Disassembly
- Remove sleeve, sleeve boot and pin boots, Fig. .
- Protect fingers with shop towel, then blow piston from caliper bore with compressed air.
- Remove piston boot, then pry piston seal from caliper bore using a suitable screwdriver.
Assembly
- Clean all components with suitable cleaner.
- Inspect caliper bore, piston and carrier for damage or excessive wear.
- Apply rubber grease to new piston seal, then install piston...
CLICK HERE TO GET FULL ACCESS TO 1992 Hyundai Excel BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Hyundai Excel AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Hyundai Excel cars and light trucks from 1990+.
HYUNDAI, HYDRAULIC BRAKE SYSTEM -> MASTER CYLINDER OVERHAUL -> EXCEPT SONATA w/BENDIX SYSTEM -> SONATA w/BENDIX SYSTEM
Vehicle: 1992 Hyundai Excel 1.5 L4 GAS
EXCEPT SONATA w/BENDIX SYSTEM
On Scoupe models, do not remove proportioning valves from master cylinder unless master cylinder replacement is necessary.
- Remove reservoir cap, drain brake fluid into a suitable container, then remove reservoir from master cylinder, Figs. through .
- On all models, remove snap ring while depressing piston with a blunt tool. If necessary, secure master cylinder in a suitable soft jawed vise.
- On except Sonata, remove primary and secondary pistons from master cylinder body. Do not disassemble primary and secondary pistons.
- On Sonata, remove p...
CLICK HERE TO GET FULL ACCESS TO 1992 Hyundai Excel BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1992 Hyundai Excel AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1992 Hyundai Excel cars and light trucks from 1990+.
HYUNDAI, HYDRAULIC BRAKE SYSTEM -> BLEEDING BRAKES
Vehicle: 1992 Hyundai Excel GL 1.5 L4 GAS
- Fill master cylinder reservoir with brake fluid.
- Using a suitable length and diameter of vinyl hose, insert end of hose into a container full of brake fluid.
- Secure other end of hose to wheel cylinder bleeder plug farthest from master cylinder.
- An assistant should depress brake ped...
CLICK HERE TO GET FULL ACCESS TO 1992 Hyundai Excel BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1992 Hyundai Excel vehicle. |
Access the Complete guide! |