Auto Parts Search
Mercury Mystique CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Mercury REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Year
2000 | 1999 | 1998 | 1997 |
1996 | 1995 |
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about Mercury Mystique car and truck repair procedures including Mercury engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up & drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix your Mercury Mystique automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR Mercury Mystique AUTOMOBILES
Air Conditioner and Heater Service Includes module configuration procedures, general service, maintenance, automatic temperature control, compressor services, electric cooling fans, vacuum diagrams, specifications, and manual air conditioning and heater diagnostics and replacement procedures for domestic and imported Mercury Mystique cars and light trucks from 1990+
Component Replacement & Adjustment -> Passenger Cars -> ACCUMULATOR/DRIER, REPLACE -> ASPIRE -> CAPRI -> CONTINENTAL, COUGAR, MARK VIII, MUSTANG, SABLE, TAURUS & THUNDERBIRD -> CONTOUR & MYSTIQUE -> CROWN VICTORIA, GRAND MARQUIS & TOWN CAR -> ESCORT, TEMPO, TOPAZ & TRACER -> PROBE
Vehicle: 1995 Mercury Mystique GS 2.5 V6 GAS
ASPIRE
- Discharge and recover system.
- Disconnect battery cables and remove battery.
- Remove radiator coolant recovery reservoir.
- Disconnect A/C pressure cutoff switch electrical connector.
- Disconnect jumper line and liquid line from suction accumulator/drier. Discard O-rings.
- Remove two clamp screws and remove suction accumulator/drier.
- Reverse procedure to install. Use new O-ring lubricated with refrigerant oil. When replacing suction accumulator/drier, add one ounce of refrigerant oil to high pressure port of compressor.
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR Mercury Mystique AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported Mercury Mystique cars and light trucks from 1990+.
Power Brake Units -> Adjustments -> Bendix Type -> Escort, Tracer & ZX2 -> Except Escort, Tracer & ZX2 -> Pushrod -> Single Diaphragm Booster
Vehicle: 1998 Mercury Mystique GS 2.0 L4 GAS
On Vehicles Equipped With Anti-Lock Brakes Refer To "Anti-Lock Brakes".
Pushrod
Proper adjustment of the master cylinder pushrod is necessary to ensure proper operation of the power brake system. A pushrod that is too long will prevent the master cylinder piston from completely releasing hydraulic pressure, eventually causing the brakes to drag. A pushrod that is too short will cause excessive brake pedal travel and cause groaning noises to come from the booster when the brakes are applied. A properly adjusted pushrod that remains assembled to the booster with which is was matched durin...
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR Mercury Mystique AUTOMOBILES
Fuel filter replacement procedures with corresponding images for most domestic and imported Mercury Mystique cars and light trucks sold in the U.S. for 1980+.
Ford Motor Co. Passenger Cars -> Fuel Shutoff Switch Location -> 1995-2000 Contour, Mystique & 1999-2000 Cougar
Vehicle: 1996 Mercury Mystique GS 2.5 V6 GAS
The switch is located u...
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR Mercury Mystique AUTOMOBILES
Includes CV axle, universal joint, and driveline replacement, for domestic and imported Mercury Mystique cars and light trucks from 1990+.
CV AXLE SHAFT, Replace -> Intermediate -> Left -> Right
Vehicle: 1998 Mercury Mystique GS 2.0 L4 GAS
Left
- Use an Allen key to stop piston rod from turning.
- Loosen suspension strut nut five turns.
- Loosen wheel hub retaining nut and wheel nuts.
- Raise and support vehicle.
- Remove wheel.
- Remove wheel hub retaining nut.
- On models with automatic transaxle, drain automatic transmission fluid.
- On all models, remove splash shields.
- Detach suspension.
- Disconnect stabilizer link end from suspension strut.
- Disconnect tie-rod end.
- Disconnect lower suspension arm from wheel knuckle.
- Disconnect wiring harness bracket from suspension strut.
- To avoid damage to CV joints and boots, do not bend inner CV ...
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR Mercury Mystique AUTOMOBILES
Includes starter and alternator replacement procedures for domestic and imported Mercury Mystique cars and light trucks from 1990+.
Alternator, Replace
Vehicle: 1997 Mercury Mystique GS 2.5 V6 GAS
- Disconnect battery ground cable.
- Disengage alternator drive belt from alternator pulley.
- Raise and support vehicle, then remove righthand wheel and tire.
- Remove righthand outer tie rod end from righthand spindle.
- Remove front and rear Y pipe flange fasteners from exhaust manifolds.
- Remove stud bolt and nut retainer from oil pan, then remove remaining nuts and bolts from U pipe outlet connection.
- Discard exhaust converter inlet gasket, then remove Y pipe.
- Disconnect wire harness attachment...
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR Mercury Mystique AUTOMOBILES
Cabin air filter locations and replacement procedures with corresponding images for most domestic and imported Mercury Mystique cars and light trucks sold in the U.S. as equipped to the current model year.
Cabin Air Filter Service -> Ford Motor Co. -> 1998-2000 Contour, Mystique & 1999-2002 Cougar
Vehicle: 2000 Mercury Mystique 2.5 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Position windshield wipers in the Park position.
- Disconnect and isolate the battery ground cable.
- Lift up the plastic wiper arm retaining nut covers.
- Remove the wiper arm retaining nuts.
- Lift up the wiper arms.
- Remove the wiper arms by moving them from side to side.
- Open the hood.
- Remove the plastic screw covers from the cowl grille retaining screws.
- Remove the cowl grille re...
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR Mercury Mystique AUTOMOBILES
Maintenance lamp reset procedures with corresponding images for most domestic and imported Mercury Mystique cars and light trucks sold in the U.S. from 1990+.
Ford Motor Co. Cars -> Check Engine Lamp/Malfunction Indicator Lamp (MIL)/Service Engine Soon Lamp -> 1998-2006 Models -> Keep Alive Memory (KAM) Reset & PCM Reset Less Electronic Tester -> PCM Reset Using Generic Scan Tool
Vehicle: 1999 Mercury Mystique 2.0 L4 GAS
This lamp should light when the ignition is turned On. After engine starts, the lamp should go off, unless a fault condition is detected by the EEC-V system. If the lamp remains On or starts to blink, a diagnostic trouble code is stored in the PCM. Following diagnosis and repair, the Check Engine/MIL lamp will automatically reset when stored diagnostic trouble codes are cleared from PCM memory. The PCM reset procedure allows the scan tool to command the PCM to clear all diagnostic trouble codes.
A temporary fault such as running out of fuel, poor quality or water in fuel or loos...
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR Mercury Mystique AUTOMOBILES
Includes radiator, cooling and heater hose replacement procedures for domestic and imported Mercury Mystique cars and light trucks from 1990+
Radiator, Replace
Vehicle: 1995 Mercury Mystique GS 2.0 L4 GAS
- Drain engine cooling system then disconnect battery ground cable.
- Remove upper radiator hose from radiator.
- On models equipped with automatic transaxle,remove transaxle oil cooler tube from oil cooler inlet fitting.
- On all models, remove fan shroud to radiator nut, then raise and support vehicle.
- Remove lower radiator hose from radiator.
- On models equipped with automatic ...
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR Mercury Mystique AUTOMOBILES
Serpentine belt replacement procedures with corresponding images for most domestic and imported Mercury Mystique cars and light trucks sold in the U.S. from 1990+.
Serpentine Drive Belt, Replace
Vehicle: 1995 Mercury Mystique GS 2.0 L4 GAS
Minor cracks in the V-grooved portion of the drive belt are considered normal and acceptable. If the drive belt has chunks missing from the ribs, the drive belt should be replaced.
Conditions requiring drive belt replacement are rib chunk out, severe glazing, frayed cords, etc. Replace any drive belt exhibiting one of these conditions.
- Raise and support vehicle.
- Loosen drive belt tensioner with 13 mm...
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR Mercury Mystique AUTOMOBILES
Component location diagrams for most Mercury Mystique cars and light trucks sold in the U.S. from 1990+.
Junction Box Component Locations Diagram for 2000 Mercury Mystique 2.5 V6 GAS Components on diagram: |
Rear Doors Diagram for 1998 Mercury Mystique LS 2.5 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR Mercury Mystique AUTOMOBILES
OEM drawn wiring diagrams for most Mercury Mystique cars and light trucks sold in the U.S.
1997 Mercury Mystique LS 2.5 V6 GAS Wiring Diagram Components on diagram: |
1995 Mercury Mystique GS 2.0 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR Mercury Mystique AUTOMOBILES
OEM TSB listings for most Mercury Mystique cars and light trucks sold in the U.S. from 1985+.
Document: PASSIVE ANTI THEFT SYSTEM - DIAGNOSTIC SERVICE TIPS Vehicle: 2000 Mercury Mystique 2.0 L4 GAS Auto Systems: |
Document: WINDNOISE AROUND SIDE DOOR(S) - TIP - REV Vehicle: 1997 Mercury Mystique GS 2.5 V6 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR Mercury Mystique AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most Mercury Mystique cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most Mercury Mystique cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most Mercury Mystique cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most Mercury Mystique cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO Mercury Mystique SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your Mercury Mystique vehicle. |
Access the Complete guide! |