Auto Parts Search
2009 Saturn VUE CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Saturn REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Saturn VUE AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2009 Saturn VUE XE 3.5 V6 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2009 Saturn VUE DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Saturn VUE AUTOMOBILES
Component Locations
Vehicle: 2009 Saturn VUE XE 3.5 V6 GAS
Refer to F...
CLICK HERE TO GET FULL ACCESS TO 2009 Saturn VUE TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Saturn VUE AUTOMOBILES
Starter, Replace
Vehicle: 2009 Saturn VUE RED Line 3.6 V6 GAS
- Disconnect battery ground cable.
- Raise and support vehicle. To avoid any vehicle damage, serious personal injury or death when major components are removed from vehicle and vehicle is supported by a hoist, support vehicle with jack stands at opposite end from which components are being removed and strap vehicle to hoist.
- Remove left side catalytic convertor.
- Disconnect starter motor e...
CLICK HERE TO GET FULL ACCESS TO 2009 Saturn VUE STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 Saturn VUE AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2008-09 Vue
Vehicle: 2009 Saturn VUE Hybrid 2.4 L4 ELECTRIC/GAS
Under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles or at Maintenance II as indicated on the DIC (Driver Information Center). In dusty areas change the cabin air filter more often.
- Open the instrument panel compartment door.
- Remove the instrument panel compartment opening trim panel, Fig. .
- Remove the instrument panel compartment retaining screws, Fig. .
- Lift the glove compartment from the instrument panel and disconnect the electrical connector.
- Through the instrument panel compartment opening, release the cabin air filter access doo...
CLICK HERE TO GET FULL ACCESS TO 2009 Saturn VUE CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Saturn VUE AUTOMOBILES
General Motors Corp./Saturn Trucks -> Check Engine Oil Level ->
Vehicle: 2009 Saturn VUE Hybrid 2.4 L4 ELECTRIC/GAS
This system is used to indicate a low engine oil level condition. The lamp should light during engine starting. If oil level is sufficient, the lamp should go off when engine is operating. If oil level is low the...
CLICK HERE TO GET FULL ACCESS TO 2009 Saturn VUE MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Saturn VUE AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2009 Saturn VUE XE 2.4 L4 GAS
Inlet
- Drain cooling system into a suitable container.
- Release clamp on heater inlet hose at heater core.
- Remove hose from heater core.
- Release clamp on heater inlet hose at engine.
- Remove hose from engine.
- Remove hose from vehicle.
- Reverse procedure to...
CLICK HERE TO GET FULL ACCESS TO 2009 Saturn VUE RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Saturn VUE AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Saturn VUE XR 3.6 V6 GAS
- Raise and support vehicle.
- Remove engine splash shield.
- Remove right side engine mount bracket.
- Completely remove lower engine mount bracket bolt.
- Rotate or lift the belt tensioner arm clockwise, using a suitable too...
CLICK HERE TO GET FULL ACCESS TO 2009 Saturn VUE SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Saturn VUE AUTOMOBILES
OEM TSB listings for most 2009 Saturn VUE cars and light trucks sold in the U.S. from 1985+.
Document: BluetoothA® Option Availability Vehicle: 2009 Saturn VUE RED Line 3.6 V6 GAS Auto Systems: |
Document: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE Vehicle: 2009 Saturn VUE RED Line 3.6 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Saturn VUE TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Saturn VUE AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Saturn VUE cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Saturn VUE cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Saturn VUE cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Saturn VUE cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Saturn VUE SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Saturn VUE vehicle. |
Access the Complete guide! |