Auto Parts Search
2009 Audi TT CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Audi REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Audi TT AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2009 Audi TT 2.0 L4 GAS
Front
- Remove wheel trim. Detach trim cap for light-alloy wheels using puller in vehicle tool kit.
- Loosen driveshaft collar bolt only 90°, so as to not damage wheel bearing. Vehicle must be standing on its wheels when loosening and tightening collar bolt to reduce risk of accident.
- Remove wheel and tire assembly.
- Screw in all five wheel bolts hand-tight.
- With an assistant applying the brakes, remove driveshaft collar bolt from the driveshaft. If collar bolt is loose or has been removed, wheel bearings must not be loaded. If wheel bearings are loaded with weight of vehicle, whee...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi TT DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Audi TT AUTOMOBILES
Component Locations
Vehicle: 2009 Audi TT 2.0 L4 GAS
Refer to F...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi TT TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Audi TT AUTOMOBILES
Starter, Replace
Vehicle: 2009 Audi TT 2.0 L4 GAS
- Disconnect battery ground cable.
- Remove electrical connector from solenoid.
- Remove terminal B+ protective cap.
- Remove nut and terminal B+ from solenoid.
- Remove start...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi TT STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 Audi TT AUTOMOBILES
Cabin Air Filter Service -> Audi -> 2006-09 A3 & 2008-09 TT
Vehicle: 2009 Audi TT 2.0 L4 GAS
The cabin air filter should be replaced at 15,000 miles, then every 20,000 miles.
- Cover front passenger side floor mat area with paper.
- From under the right side of the instrument panel, detach the clips securing the insulation mat, then remove the mat, Fig. .
- Remove the ca...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi TT CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Audi TT AUTOMOBILES
Audi -> Service Reset Message -> 2008-09 TT
Vehicle: 2009 Audi TT 2.0 L4 GAS
To reset service interval display, switch ignition to on. Press the reset button until the message SERVICE appears. Press the re...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi TT MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Audi TT AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2009 Audi TT 2.0 L4 GAS
Inlet
- Drain coolant into a suitable container.
- Reposition hose clamp at heater core and remove hose.
- Reposition hose clamp at cylinder head and remove hose.
- Remove hose from vehicle.
- Reverse procedure ...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi TT RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Audi TT AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Audi TT 2.0 L4 GAS
- Disconnect electrical connector on Mass Air Flow (MAF) Sensor .
- Open clips and remove air guide hose from mass air flow sensor
- Remove front air intake connector on lock carrier.
- Remove engine cover.
- Remove EVAP canister with connected lines upward out of retainer and...
CLICK HERE TO GET FULL ACCESS TO 2009 Audi TT SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Audi TT AUTOMOBILES
OEM TSB listings for most 2009 Audi TT cars and light trucks sold in the U.S. from 1985+.
Document: AIRBAG / PYROTECHNIC SAFETY BELT DEPLOYMENT INQUIRIES - REVISED Vehicle: 2009 Audi TT 2.0 L4 GAS Auto Systems: |
Document: AUDI TIRE PRESSURE MONITORING SYSTEMS OVERVIEW - REVISED Vehicle: 2009 Audi TT 2.0 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Audi TT TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Audi TT AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Audi TT cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Audi TT cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Audi TT cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Audi TT cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Audi TT SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Audi TT vehicle. |
Access the Complete guide! |