Auto Parts Search
2008 Chevrolet AVEO5 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2008 Chevrolet AVEO5 AUTOMOBILES
Hydraulic Brake Systems -> Troubleshooting -> Master Cylinder Internal Fluid Leakage Check -> Road Test
Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS
When troubleshooting the hydraulic brake system, perform the following inspections.
Master Cylinder Internal Fluid Leakage Check
Start engine and depress the brake pedal. If the pedal gradually falls under constant pressure, the hydraulic system may be leaking. Raise the vehicle on a lift and inspect all tubing lines and backing plates for signs of leakage. It may be required to lift or remove the carpeting or floor mats to inspect for boost...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2008 Chevrolet AVEO5 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS
- Remove hub nut.
- Raise and support vehicle.
- Remove ball joint to steering knuckle nut.
- Break ball joint loose from steering knuckle.
- Push axle...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2008 Chevrolet AVEO5 AUTOMOBILES
Reset Procedures
Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS
The Low Tire Pressure warning lamp and/or the DIC (Driver Information Center) Low Tire Pressure message can be cl...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2008 Chevrolet AVEO5 AUTOMOBILES
Alternator, Replace
Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS
- Disconnect battery ground cable.
- Disconnect intake air temperature (IAT) sensor electrical connector from air intake tube.
- Remove breather tube clamp and all other clamps, then air intake tube.
- Disconnect ...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2008 Chevrolet AVEO5 AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2004-09 Aveo & 2009 G3
Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS
On 2004-08 models, under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
On 2009 models, under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles or at Maintenance II as indicated on the DIC (Driver Information Center). In dusty areas change the cabin air filter more often.
- Open the glove compartment door.
- Grasp the upper and lower portions of the glove compartment and pull the compartment out from the housing, Fig. .
- Through the glov...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2008 Chevrolet AVEO5 AUTOMOBILES
General Motors Corp./Saturn Cars -> Check Engine Or Service Now Soon Engine Indicator Lamps (Gasoline Engines w/Electronic Engine Controls Or EFI) -> Except LeMans, Metro, Prizm, Storm & Vibe
Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS
The Check Engine lamp should light when the ignition is turned On. When the engine is started, the lamp should go off. If the lamp remains on for 10 seconds or constantly after the engine is started, the self diagnosis system has detected a fault condition and has stored a code in the system Electronic Control Module (ECM) or Powertrain Control Module (PCM). After diagnosis and repair, the ECM memory can be cleared of codes as follows:
On models except Cadillac with DEFI, remove the ECM/PCM fuse or disconnect the battery ground cable for approximately 30...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2008 Chevrolet AVEO5 AUTOMOBILES
Radiator, Replace
Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS
- Drain engine coolant.
- Remove electric cooling fans.
- Remove upper radiator hose clamp.
- Disconnect upper and lower radiator hoses from radiator.
- Disconnect s...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2008 Chevrolet AVEO5 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS
To remove power steering pump belt, remove accessory belt in first.
- Rotate tensioner star-nut counterclockwise a...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2008 Chevrolet AVEO5 AUTOMOBILES
Component location diagrams for most 2008 Chevrolet AVEO5 cars and light trucks sold in the U.S. from 1990+.
Ignition System Diagram for 2008 Chevrolet AVEO5 LS 1.6 L4 GAS Components on diagram: |
CHMSL and License Lamps Diagram for 2008 Chevrolet AVEO5 LS 1.6 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2008 Chevrolet AVEO5 AUTOMOBILES
OEM drawn wiring diagrams for most 2008 Chevrolet AVEO5 cars and light trucks sold in the U.S.
2008 Chevrolet AVEO5 LS 1.6 L4 GAS Wiring Diagram Components on diagram: |
2008 Chevrolet AVEO5 LS 1.6 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2008 Chevrolet AVEO5 AUTOMOBILES
OEM TSB listings for most 2008 Chevrolet AVEO5 cars and light trucks sold in the U.S. from 1985+.
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2008 Chevrolet AVEO5 LS 1.6 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2008 Chevrolet AVEO5 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2008 Chevrolet AVEO5 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2008 Chevrolet AVEO5 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2008 Chevrolet AVEO5 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2008 Chevrolet AVEO5 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet AVEO5 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2008 Chevrolet AVEO5 vehicle. |
Access the Complete guide! |