2007 Toyota Tacoma REPAIR MANUAL -- HOW TO FIX YOUR CAR OR TRUCK

Auto Parts Search


2007 Toyota Tacoma CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Toyota REPAIR SHOPS DON'T WANT YOU TO KNOW

Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!

Help me findSearch

Select Section

Get Full Access Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2007 Toyota Tacoma car and truck repair procedures including Toyota engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up & drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix your Toyota Tacoma automobile. Try the Automotix DIY solution today!
DIY REPAIR SAMPLES > CONTINUE EXPLORING >
Using the Automotix DIY repair procedures will save you hundreds and even thousands of dollars! In addition, it will save you hours of touring the city searching for Toyota mechanics you can trust. The Automotix DIY solution is particularly affordable. A full access to the entire DIY repair procedures and diagrams for your 2007 Toyota Tacoma vehicle will cost less than a single gallon of gas. Here are some of the DIY repair tips and procedures you will find here:

DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Toyota Tacoma AUTOMOBILES

DRIVESHAFT U-JOINT, Replace -> Assembly -> Disassemble
Vehicle: 2007 Toyota Tacoma 2.7 L4 GAS

Disassemble

This procedure describes a driveline equipped with cardan joint in tube yoke. Driveline equipped with companion/slip yoke repeat steps to remove remaining cardan joint.

  • Place driveshaft on suitable workbench. Do not damage driveshaft when servicing on workbench. Ensure driveline and components are reference marked to prevent driveline imbalance.
  • Tap outside of bearing cap with a drift to loosen snap ring.
  • Remove snap rings from both sides of yoke using suitable tool.
  • Position yoke with grease fitting pointing up, if equipped.
  • Position socket with an inside diam...

CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES

TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Toyota Tacoma AUTOMOBILES

Reset Procedures
Vehicle: 2007 Toyota Tacoma PRE Runner 2.7 L4 GAS

This warning lamp will illuminate when tire pressure falls below a specified psi. When the warning lamp illuminates, check the air...

CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma TIRE PRESSURE MONITORING SYSTEM PROCEDURES

STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Toyota Tacoma AUTOMOBILES

Starter, Replace
Vehicle: 2007 Toyota Tacoma X-RUNNER 4.0 V6 GAS

  • Position vehicle on lift and ensure transaxle is in neutral position.
  • Disconnect battery ground cable.
  • Raise vehicle on suitable lift.
  • Remove bolts from engine rear under cover assembly then remove under cover.
  • On models equipped with 2WD, remove bolts and separate engine wiring harness.
  • On models equipped with 4WD, disconnect bank two heated oxygen sensor connector.
  • Remove bolts, nuts, compression springs, and gaskets securing front exhaust pipe assembly.
  • Remove clips securing lefthand rear splash shield then remove splash shield.
  • Loosen bolt upper bolt securing steering intermediate ...

CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma STARTER & ALTERNATOR REPLACEMENT PROCEDURES

CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Toyota Tacoma AUTOMOBILES

Cabin Air Filter Service -> Toyota -> 2006-09 Tacoma
Vehicle: 2007 Toyota Tacoma 4.0 V6 GAS

On 2006 models, the cabin air filter should be replaced every 36 months or 30,000 miles. The filter should be replaced more often if air flow is less than normal.

On 2007-09 models, the cabin air filter should be replaced every 24 months or 20,000 miles. The filter should be replaced more often if air flow is less than normal.

  • Open the glove compartment door.
  • Slide off damper rod from glove compartment door, Fig. .
  • Push inward at each side of the glove compartment door to disengage the retainers, then lower...

CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES

MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Toyota Tacoma AUTOMOBILES

Toyota -> Air Bag Warning Lamp -> 2003-09 Tacoma
Vehicle: 2007 Toyota Tacoma PRE Runner 2.7 L4 GAS

  • Connect two service wires to terminals Tc and CG of data link connector.
  • Turn ignition switch to On position and wait for approximately 6 seconds.
  • SRS warning lamps will illuminate 2-4 seconds later. Within 1-5 seconds, ground terminal Tc of DLC.
  • SRS warning lamp will go off within 2-4 seconds. Within 1-5 seconds, release...

CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma MAINTENANCE LAMP RESET PROCEDURES

RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Toyota Tacoma AUTOMOBILES

Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2007 Toyota Tacoma X-RUNNER 4.0 V6 GAS

Inlet

  • Disconnect battery ground cable.
  • Drain cooling system into a suitable container by loosening drain plug of radiator.
  • Reposition hose clamp at heater core.
  • Remove hose from heater core.
  • Reposition hose clamp at water outlet.
  • Remove hose from water outlet.
  • Remove hose from vehicle.
  • Reverse procedure to install.

Outlet

  • Disconnect battery ground cable.
  • Drain cooling system into a suitable container by loosening drain plug of radiator.
  • Reposition hose clamp a...

CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma RADIATOR & HOSE REPLACEMENT PROCEDURES

SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Toyota Tacoma AUTOMOBILES

Serpentine Drive Belt, Replace
Vehicle: 2007 Toyota Tacoma PRE Runner 2.7 L4 GAS

  • Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...

CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma SERPENTINE BELT SERVICE PROCEDURES

COMPONENT LOCATION DIAGRAMS FOR 2007 Toyota Tacoma AUTOMOBILES

Component location diagrams for most 2007 Toyota Tacoma cars and light trucks sold in the U.S. from 1990+.

Engine Compartment Connectors and Grounds Diagram for 2007 Toyota Tacoma PRE Runner 2.7 L4 GASEngine Compartment Connectors and Grounds Diagram for 2007 Toyota Tacoma PRE Runner 2.7 L4 GAS

Components on diagram:
  • Engine Room Main Wire
  • Engine Wire
  • Sensor wire
  • Connector EA1
  • Connector EB1
  • Instrument Panel Connectors and Grounds Diagram for 2007 Toyota Tacoma  2.7 L4 GASInstrument Panel Connectors and Grounds Diagram for 2007 Toyota Tacoma 2.7 L4 GAS

    Components on diagram:
  • Ground IE
  • Ground ID
  • Ground IC
  • Ground IB
  • Ground IA
  • CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma PARTS/COMPONENTS LOCATION DIAGRAMS!

    WIRING DIAGRAMS FOR 2007 Toyota Tacoma AUTOMOBILES

    OEM drawn wiring diagrams for most 2007 Toyota Tacoma cars and light trucks sold in the U.S.

    2007 Toyota Tacoma PRE Runner 4.0 V6 GAS Wiring Diagram2007 Toyota Tacoma PRE Runner 4.0 V6 GAS Wiring Diagram

    Components on diagram:
  • Data Link Connector
  • Fuel Pump Relay
  • Fuel Pump And Gauge Assembly
  • Engine Control Module
  • Fuel Pump Resistor
  • 2007 Toyota Tacoma  4.0 V6 GAS Wiring Diagram2007 Toyota Tacoma 4.0 V6 GAS Wiring Diagram

    Components on diagram:
  • Door Control Receiver
  • Left Rear Door Lock Assembly
  • Right Rear Door Lock Assembly
  • CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma WIRING DIAGRAMS!

    TECHNICAL SERVICE BULLETINS FOR 2007 Toyota Tacoma AUTOMOBILES

    OEM TSB listings for most 2007 Toyota Tacoma cars and light trucks sold in the U.S. from 1985+.

    Document: MIL ON DTC P0705
    Vehicle: 2007 Toyota Tacoma 2.7 L4 GAS

    Auto Systems:
  • Automatic Trans, Coolers, Torque Converter
  • Document: REAR SUSPENSION SQUEAK NOISE
    Vehicle: 2007 Toyota Tacoma 2.7 L4 GAS

    Symptoms:
  • Noise
  • Auto Systems:
  • Steering, Suspension
  • CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma TECHNICAL SERVICE BULLETINS!

    COMPONENT/PARTS SPECIFICATIONS FOR 2007 Toyota Tacoma AUTOMOBILES

    BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Toyota Tacoma cars and light trucks sold in the U.S. and Canada from 1970+.

    • Brake caliper mounting bolt torque
    • Brake drum runout, machining, & discard specs
    • Minimum brake lining thickness.
    • Brake rotor runout, parallelism, machining, discard, & finish specs

    A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Toyota Tacoma cars and light trucks sold in the U.S. and Canada from 1980+.

    • Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap

    COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.

    PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules

    QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Toyota Tacoma cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.

    • Automatic transmission/transaxles capacities, lubricant recommendations
    • Differential/final drive capacities, lube recommendations, grades, & viscosities
    • Final drive fill & drain plug torques
    • Number of lubrication fittings & plugs
    • Power steering, brake, & clutch fluid recommendations
    • Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
    • Number of lubrication fittings & plugs
    • Power steering, brake, & clutch fluid recommendations
    • Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
    • Severe service maintenance & interval recommendations
    • Tire sizes, wheel nut/bolt torque, pressures & rim sizes
    • Transfer case capacities, lube recommendations, grades, & viscosities

    TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Toyota Tacoma cars and light trucks sold in the U.S. and Canada from 1980+

    • Airflow sensor electrical specifications
    • Tensioning specifications for systems with automatic tensioners
    • Barometric pressure sensor specs
    • Battery group number and cranking performance
    • Crankshaft & camshaft position sensor resistance
    • Engine compression pressures
    • Coolant temperature sensor specs
    • Computer advance.
    • Diesel fuel temperature sensor resistance.
    • Distributor advance specifications
    • Ignition pickup coil resistance
    • Exhaust gas recirculation temperature sensor resistance
    • Engine fastener torque values
    • Firing order diagrams
    • Fuel system pressures
    • Generator (alternator) specs
    • Intake air temperature sensor specs
    • Ignition coil specifications
    • Fuel injector resistance
    • Engine idle speeds
    • Knock sensor resistance
    • Manifold absolute pressure sensor specs
    • Mixture control solenoid resistance
    • Voltage regulator specs
    • Spark plug applications & gaps
    • Starter motor electrical specs.
    • Tensioning specifications for systems without automatic tensioners
    • Throttle body temperature sensor resistance
    • Ignition timing in degrees at rpm
    • Transmission oil temperature sensor resistance
    • Throttle position sensor specs
    • Vacuum sensor valve specs

    CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tacoma SPECIFICATIONS DATA!

    Shop online for auto body parts, engines, wheels, lights...

    Click here to view more details2003 Toyota Tacoma Door Handle, Front, Driver Side, With keyhole; Ensures precise and perfect fit for a reliable and efficient performance; Adds unique and distinctive styling that gives your vehicle a custom look; With 18 months limited Prozone warranty..

    Source: Auto Body Parts Store

    $30.59

    Click here to view more details about 1999 Toyota Tacoma Tail Light, Passenger Side1999 Toyota Tacoma Tail Light, Passenger Side.

    Source: Auto Body Parts Store

    $44.62

    Click here to view more details1998 Toyota Celica 14" Aftermarket Wheels Covers, Aftermarket Wheels Covers; 14 Inch; Silver Finish; ABS; 11 Spoke; 5 Lug; Cover; Metal Clip Retention, , .

    Source: Wheels / Rims, Mirrors & Lights Store

    $27.50

    Click here to view more details2002 Toyota Tacoma V6, 3.4 L, 3378 CC Rebuilt Engine, Warranty: 3-Year/100,000 Mile, .

    Source: Rebuilt Engines Store

    Ad Hoc

    Click here to view more details2008 Toyota Tacoma Used Condenser Assembly, 4.0, FLR, 4X2, Very Good.

    Source: Used Auto Parts Store

    $123.00

    Click here to view more details2009 Toyota Tacoma Used Bumper Bar, Front, 2DR, Gray, BASE bar w/LH&RH mtg. brackets (stays), Very Good.

    Source: Used Auto Parts Store

    $322.00
    More parts
    Help me findSearch
    Auto Repair Quick Search
    Help me find
    Search DIY repair manuals by VIN...
    Vehicle Identification Number is a unique serial number used by the automotive industry to identify individual motor vehicles

    Find out what info we have for your vehicle

    Get the Complete Technical Service Bulletins!
    Get the Complete Technical Service Bulletins!Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Toyota Tacoma vehicle.
    Access the Complete guide!
    Need To Fix Your Car or Truck?
    Save Money With Free Car Insurance Quote
    FREE car insurance quote
    Enter Zip Code:
    Auto Repair Quick Search
    Help me find