Auto Parts Search
2007 Pontiac Solstice CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Pontiac Solstice AUTOMOBILES
Disc Brakes -> Saturn/GM Single Piston -> Adjustments -> AURA -> Cobalt, G5 & ION -> L-Series -> Parking Brake -> Solstice & SKY
Vehicle: 2007 Pontiac Solstice GXP 2.0 L4 GAS
Parking Brake
AURA
- Apply and release park brake several times. Ensure lever is released completely.
- Turn ignition to On position and ensure red BRAKE lamp is not illuminated. If lamp is illuminated, verify following:
- Park brake lever is in released position and against stop.
- There is no slack in park brake cable.
- Raise and support vehicle.
- With parking brake pedal fully released, check parking brake levers on rear calipers. The levers should be against stops on caliper housings.
- Apply and release parking three to five times, this will allow cable tensioner to take up slack in the parking b...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Pontiac Solstice AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2007 Pontiac Solstice GXP 2.0 L4 GAS
Front
- Raise and support vehicle.
- Remove and discard propeller shaft sliding yoke bolts, nuts and washers.
- Remove and discard propeller shaft coupling bolts.
- Remove propeller shaft.
- Reverse procedure to install, noting the following:
- Lubricate sliding yoke with suitable transmission lubricant.
- Torque propeller shaft coupling to propeller shaft bolts to 13 ft. lbs. and then an additional 55°
- Torque propeller shaft yoke to propeller coupling bolts 13 ft. lbs. and then an additional 55°.
Rear
- Raise and support vehicle rear, then remove rear tire and wheel assemblies.
- Remove two support han...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Pontiac Solstice AUTOMOBILES
Alternator, Replace
Vehicle: 2007 Pontiac Solstice 2.4 L4 GAS
- Disconnect battery ground cable.
- Rotate or lift belt tensioner arm, using a suitable tool to relieve tension from drive belt.
- Remove drive belt.
- Remove engine harness ground terminal bo...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Pontiac Solstice AUTOMOBILES
General Motors Corp./Saturn Cars -> Low Coolant Lamp ->
Vehicle: 2007 Pontiac Solstice 2.4 L4 GAS
This lamp should light when engine coolant level in the radiator drops below a predetermined le...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Pontiac Solstice AUTOMOBILES
Radiator, Replace
Vehicle: 2007 Pontiac Solstice 2.4 L4 GAS
- Drain cooling system into suitable container.
- Remove mounting bolts and radiator front air deflector, then the retainer and shroud air inlet.
- Remove air cleaner outlet duct resonator and Positive Crankcase Ventilation (PCV) hose clamps.
- Remove air cleaner outlet duct resonator.
- Disconnect cooling fan motor electrical connector.
- Remove mounting bolts, shroud, cooling fan and motor.
- Remove radiator inlet and outlet hoses, then the surge tank inlet hose.
- Remove air cleaner stud, then the mounting nuts and radiator upper bracket.
- Remove mounting bolts, air conditioning condenser and radia...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Pontiac Solstice AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Pontiac Solstice GXP 2.0 L4 GAS
- Grasp intake manifold cover and disconnect studs.
- Remove intake manifold cover, oil fill cap and insulator. Install oil fill cap.
- Rotate power steering pump belt tensioner pulley clockwise and remove belt.
- Lower vehicle.
- Remove charge air cooler inlet pipe mounting bolt at rear bracket.
- Remove mounting nut and charge air cooler rear bracket.
- Remove charge air cooler inlet pipe mounting bolt at front bracket.
- Loosen charge air cooler clamp at inlet pipe. and inlet pipe clamp at pipe.
- Remove charge air cooler inlet pipe.
- Disconnect intake air pressure and temperature sensor ...
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Pontiac Solstice AUTOMOBILES
Component location diagrams for most 2007 Pontiac Solstice cars and light trucks sold in the U.S. from 1990+.
Underhood Components Diagram for 2007 Pontiac Solstice 2.4 L4 GAS Components on diagram: |
Underbody Components Diagram for 2007 Pontiac Solstice GXP 2.0 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Pontiac Solstice AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Pontiac Solstice cars and light trucks sold in the U.S.
2007 Pontiac Solstice 2.4 L4 GAS Wiring Diagram Components on diagram: |
2007 Pontiac Solstice GXP 2.0 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Pontiac Solstice AUTOMOBILES
OEM TSB listings for most 2007 Pontiac Solstice cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2007 Pontiac Solstice 2.4 L4 GAS Auto Systems: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2007 Pontiac Solstice 2.4 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Pontiac Solstice AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Pontiac Solstice cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Pontiac Solstice cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Pontiac Solstice cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Pontiac Solstice cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Pontiac Solstice SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Pontiac Solstice vehicle. |
Access the Complete guide! |