Auto Parts Search
2007 Ford Five Hundred CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Ford REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Ford Five Hundred AUTOMOBILES
Anti-Lock Brakes -> Five Hundred, Freestyle & Montego -> Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Connector Pin Identification -> Diagnostic Trouble Code Interpretation -> Pinpoint Tests
Vehicle: 2007 Ford Five Hundred SEL 3.0 V6 GAS
Accessing Diagnostic Trouble Codes
- Connect suitably programmed scan tool to data link connector (DLC) located under instrument panel.
- Turn ignition switch to Run position.
- Follow instructions on screen and record all diagnostic trouble codes.
- If any DTCs appear during Self-Test, refer to "Diagnostic Trouble Code Interpretation."
- If scan tool reports "System Passed" proceed to symptom chart to continue diagnostics.
Diagnostic Trou...
[[table data]]CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Ford Five Hundred AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2007 Ford Five Hundred Limited 3.0 V6 GAS
Failure to correctly index-mark driveshaft will lead to noise, vibration or harshness (NVH) problems. Index-mark driveshaft to rear axle pinion flange, power take off (PTO) flange and center bearing bracket. Index-mark driveshaft.
- With vehicle in NEUTRAL, raise and support vehicle.
- Remove exhaust system at flex pipe.
- Remove exhaust support brace bolts, then exhaust support brace.
- Always install new drivesh...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Ford Five Hundred AUTOMOBILES
Starter, Replace
Vehicle: 2007 Ford Five Hundred Limited 3.0 V6 GAS
The heavy gauge input lead connected to starter solenoid is hot at all times. Ensure protective cap is installed over terminal and is replaced after service.
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove lower air deflector.
- Remove starter solenoid safety cap.
- Remove starter sol...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Ford Five Hundred AUTOMOBILES
Ford Motor Co. Cars -> Powertrain Malfunction Indicator ->
Vehicle: 2007 Ford Five Hundred Limited 3.0 V6 GAS
This lamp should light when the ignition is turned On. After engine starts, the lamp should go off, unless a fault condition is detected in the powertrain system. If the lamp remains On a diagnostic trouble code is stored in the PCM. Following diagnosis and repair, the Powertrain Malfunction Indicator will automatically reset when stored diagnostic trouble codes are cleared from PCM memory. The PCM reset procedure allows the scan tool to command the PCM to clear all diagnostic trouble codes.
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Ford Five Hundred AUTOMOBILES
Radiator, Replace
Vehicle: 2007 Ford Five Hundred SEL 3.0 V6 GAS
- Drain cooling system into suitable container.
- Remove battery and battery tray.
- Disconnect upper radiator hose.
- Disconnect degas bottle return hose.
- Disconnect upper transaxle cooler line using suitable disconnect tool.
- Remove air conditioning condenser mounting bolts.
- Raise a...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Ford Five Hundred AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Ford Five Hundred SEL 3.0 V6 GAS
- Remove accessory drive belt splash shield.
- Rotate drive be...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Ford Five Hundred AUTOMOBILES
Component location diagrams for most 2007 Ford Five Hundred cars and light trucks sold in the U.S. from 1990+.
Instrument Panel Diagram for 2007 Ford Five Hundred Limited 3.0 V6 GAS Components on diagram: |
Body Components Diagram for 2007 Ford Five Hundred Limited 3.0 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Ford Five Hundred AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Ford Five Hundred cars and light trucks sold in the U.S.
2007 Ford Five Hundred Limited 3.0 V6 GAS Wiring Diagram Components on diagram: |
2007 Ford Five Hundred SEL 3.0 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Ford Five Hundred AUTOMOBILES
OEM TSB listings for most 2007 Ford Five Hundred cars and light trucks sold in the U.S. from 1985+.
Document: INOPERATIVE HEATED SEATS Vehicle: 2007 Ford Five Hundred Limited 3.0 V6 GAS Symptoms: |
Document: TRANSMISSION HARD SHIFTING - NO DTCS - MILEAGE ABOVE 20,000 MILES - REVISED Vehicle: 2007 Ford Five Hundred Limited 3.0 V6 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Ford Five Hundred AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Ford Five Hundred cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Ford Five Hundred cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Ford Five Hundred cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Ford Five Hundred cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Five Hundred SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Ford Five Hundred vehicle. |
Access the Complete guide! |