Auto Parts Search
2007 Chevrolet Silverado 1500 HD CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
Hydraulic Brake Systems -> Component Service -> Assemble -> Bendix Master Cylinder -> Delco Master Cylinder -> Disassemble -> Wheel Cylinder
Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS
Delco Master Cylinder
When performing the following procedures, refer to Fig. noting that the composite reservoir may vary in design.
Disassemble
- Remove master cylinder from vehicle.
- Remove reservoir cover and diaphragm. Discard old brake fluid in reservoir.
- Inspect cover and diaphragm. Replace if cut, cracked or deformed.
- Remove fluid level switch and proportioning valve assembly, if equipped.
- Depress primary piston and remove lock ring.
- Plug primary fluid outlet (outlet nearest to cowl when master cylinder is installed), then apply compressed air into secondary fluid outlet to remo...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
Description
Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS
The TPM (Tire Pressure Monitor) System warns the driver when a significant loss, or gain of tire pressure occurs in any of the four tires and allows the driver to display the individual tire pressures and the locations on the DIC (Driver Information Center) display. The system uses the PCM (Powertrain Control Module), IPC (Instrument Panel Cluster), DIC, remote control door lock receiver, a radio frequency transmitting pressure sensor in each wheel assembly and the serial data circuit.
When the vehicle is stationary, the sensor is inactive. When the vehicle is operated and as the veh...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
Alternator, Replace
Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS
- Disconnect battery ground cable.
- Disconnect positive crankcase ventilation hose from air cleaner outlet resonator.
- Loosen air cleaner outlet resonator clamps at mass air flow intake air temperature sensor and at throttle body.
- Remove air cleaner outlet resonator.
- Remove drive belt using suitable tools.
- Remove engine wiring harness clip from air conditioning compressor and condenser hose bracket.
- Remove air conditioning compressor and condenser hose bracket bolt.
- Remove heate...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
General Motors Corp./Saturn Trucks -> Reduce Engine Power Indicator Lamp ->
Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS
The Reduce Engine Power indicator lamp should light for a approximately 3 seconds when the ignition is turned On as a bulb check. If the warning lamp turns On during vehicle operation, a vehicl...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
Radiator, Replace
Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS
- Drain radiator coolant into suitable container.
- Remove upper and lower radiator hoses.
- Remove mounting bolts and lower fan shroud.
- Remove engine vent hose and surge take hose.
- Disconnect engine oi...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS
- Remove air cleaner outlet duct.
- Rotate tensioner clockwise to release belt tension using breaker bar with hex-head socket, then remove drive belt.
- If replacing Air conditioner drive belt, rotate tensioner clockwise to release belt tension using breaker bar or ratchet, then remove belt.
- Clean and inspect belt su...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
Component location diagrams for most 2007 Chevrolet Silverado 1500 HD cars and light trucks sold in the U.S. from 1990+.
Instrument Panel Diagram for 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS Components on diagram: |
Door Components Diagram for 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Chevrolet Silverado 1500 HD cars and light trucks sold in the U.S.
2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS Wiring Diagram Components on diagram: |
2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
OEM TSB listings for most 2007 Chevrolet Silverado 1500 HD cars and light trucks sold in the U.S. from 1985+.
Document: Second Order Prop Shaft Vibration Or Launch Shudder Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS Symptoms: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2007 Chevrolet Silverado 1500 HD Classic LT 6.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Chevrolet Silverado 1500 HD AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Chevrolet Silverado 1500 HD cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Chevrolet Silverado 1500 HD cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Chevrolet Silverado 1500 HD cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Chevrolet Silverado 1500 HD cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado 1500 HD SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Chevrolet Silverado 1500 HD vehicle. |
Access the Complete guide! |