Auto Parts Search
2007 Chevrolet Colorado CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Colorado AUTOMOBILES
Disc Brakes -> Delco Dual Piston Sliding Caliper -> Description
Vehicle: 2007 Chevrolet Colorado LT 2.9 L4 GAS
The caliper mounts in a way that allows the caliper to move laterally inboard as the brake pads wear. The caliper housing is a one piece casting with the inboard side containing the piston bore. The piston seal also acts as a return mechanism for the piston.
Applying the brake pedal causes the hydraulic pressure that moves the caliper piston. The piston then forces the inboard brake pad against the inboard braking surface of the rotor. Increasing the force against...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Chevrolet Colorado AUTOMOBILES
DRIVESHAFT, Replace -> Front -> One Piece Driveshaft -> Rear -> Two Piece Driveshaft
Vehicle: 2007 Chevrolet Colorado LS 2.9 L4 GAS
Front
- Raise and support vehicle.
- Mark the front U-joint to the pinion yoke on the front differential.
- Mark the relationship of the rear U-joint to the transfer case drive flange.
- Remove the retaining nuts and bolts from the drive flange.
- Remove the clamps and retaining bolts from the front drive axle pinion flange.
- Remove the front propeller shaft from the vehicle.
- Using tape and or a rubber band, wrap the front U-joint bearing caps to ensure the caps do not separate from the U-joint.
- Reverse procedure to install, noting the following:
- Torque front propeller shaft to the pinion flang...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Chevrolet Colorado AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic System Check -> Diagnostic Tests -> DTC C0750 Left Front Low Tire Pressure Sensor, C0755 Right Front Low Tire Pressure Sensor, C0760: Left Rear Low Tire Pressure Sensor Or C0765 Right Rear Low Tire Pressure Sensor -> DTC C0775 Low Tire Pressure System Sensors Not Learned -> Intermittent & Poor Connections -> Intermittents -> Low Tire Pressure Indicator Always On -> Low Tire Pressure Indicator Inoperative -> Poor Connections
Vehicle: 2007 Chevrolet Colorado WT 2.9 L4 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Tests
Diagnostic System Check
- Inspect the vehicle for the installation of aftermarket devices which could affect the operation of the TPMS.
- Inspect the vehicle for damage or conditions which could cause the system to malfunction.
- Verify that the scan tool selected Front and Rear Tire Pressure parameters are correct when compared to the tires actual pressure ratings. If tire pressure parameters are not correct, use scan tool spec...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Chevrolet Colorado AUTOMOBILES
Starter, Replace
Vehicle: 2007 Chevrolet Colorado WT 2.9 L4 GAS
- Disconnect battery ground cable.
- Loosen clamps and remove air cleaner outlet duct.
- Disconnect atmospheric vent hose from air cleaner resonator.
- Loosen air cleaner resonator outlet duct clamp.
- Remove air cleaner resonator bolts.
- Remove air cleaner resonator and outlet duct from engine.
- Lift upward on air cleaner resonator assembly.
- Disconnect crankcase ventilation hose from camshaft cover, then outlet duct from throttle body.
- Remove air cleaner resonator assembly.
- Disconnect evaporative emission canister purge pipe from throttle control module, using a suitable quick disconnect tool.
- Disc...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Chevrolet Colorado AUTOMOBILES
General Motors Corp./Saturn Trucks -> Service Throttle Soon Indicator Lamp ->
Vehicle: 2007 Chevrolet Colorado LT 2.9 L4 GAS
A "Service Throttle Soon" indicator lamp is mounted in the lower righthand instrument cluster corner on these models. It lights when the ignition is turned On, but should go out approximately 1-5 seconds after the engine starts.
Traditional throttle cables are no longer used on these models. The PCM receives signals from an electron...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Chevrolet Colorado AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2007 Chevrolet Colorado LT 2.9 L4 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from thermostat housing.
- Remove radiator outlet hose from thermostat housing.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator and from vehicle.
- Reverse procedure to ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Chevrolet Colorado AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Chevrolet Colorado WT 2.9 L4 GAS
- Rotate tensioner clockwise, using suitable 3/8 inch breaker bar.
- Slide drive belt from water pump pul...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Chevrolet Colorado AUTOMOBILES
Component location diagrams for most 2007 Chevrolet Colorado cars and light trucks sold in the U.S. from 1990+.
Engine Compartment Diagram for 2007 Chevrolet Colorado LT 3.7 L5 GAS Components on diagram: |
Door Components Diagram for 2007 Chevrolet Colorado LS 3.7 L5 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Chevrolet Colorado AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Chevrolet Colorado cars and light trucks sold in the U.S.
2007 Chevrolet Colorado LS 2.9 L4 GAS Wiring Diagram Components on diagram: |
2007 Chevrolet Colorado LT 3.7 L5 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Chevrolet Colorado AUTOMOBILES
OEM TSB listings for most 2007 Chevrolet Colorado cars and light trucks sold in the U.S. from 1985+.
Document: Engine Rattle Noise after R And R of the Crankshaft Balancer -Inspect Bolt Torque Vehicle: 2007 Chevrolet Colorado LT 3.7 L5 GAS Symptoms: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2007 Chevrolet Colorado LT 3.7 L5 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Chevrolet Colorado AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Chevrolet Colorado cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Chevrolet Colorado cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Chevrolet Colorado cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Chevrolet Colorado cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Colorado SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Chevrolet Colorado vehicle. |
Access the Complete guide! |