Auto Parts Search
2007 Chevrolet AVEO5 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet AVEO5 AUTOMOBILES
Power Brake Units -> Troubleshooting -> Brakes Grab -> Brakes Inefficient/Hard Pedal -> Slow Or No Release
Vehicle: 2007 Chevrolet AVEO5 LS 1.6 L4 GAS
Brakes Grab
- Contaminated, worn or faulty brake linings.
- Drum or brake rotor out-of-round.
- Faulty brake booster.
Brakes Inefficient/Hard Pedal
- Contaminated, glazed or faul...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Chevrolet AVEO5 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2007 Chevrolet AVEO5 LS 1.6 L4 GAS
- Remove hub nut.
- Raise and support vehicle.
- Remove ball joint to steering knuckle nut.
- Break ball joint loose from steering knuckle.
- Push axle...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Chevrolet AVEO5 AUTOMOBILES
Alternator, Replace
Vehicle: 2007 Chevrolet AVEO5 LS 1.6 L4 GAS
- Disconnect battery ground cable.
- Disconnect intake air temperature (IAT) sensor electrical connector from air intake tube.
- Remove breather tube clamp and all other clamps, then air intake tube.
- Disconnect ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Chevrolet AVEO5 AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2004-09 Aveo & 2009 G3
Vehicle: 2007 Chevrolet AVEO5 LS 1.6 L4 GAS
On 2004-08 models, under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
On 2009 models, under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles or at Maintenance II as indicated on the DIC (Driver Information Center). In dusty areas change the cabin air filter more often.
- Open the glove compartment door.
- Grasp the upper and lower portions of the glove compartment and pull the compartment out from the housing, Fig. .
- Through the glov...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Chevrolet AVEO5 AUTOMOBILES
General Motors Corp./Saturn Cars -> Low Coolant Lamp ->
Vehicle: 2007 Chevrolet AVEO5 LS 1.6 L4 GAS
This lamp should light when engine coolant level in the radiator drops below a predetermined le...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Chevrolet AVEO5 AUTOMOBILES
Radiator, Replace
Vehicle: 2007 Chevrolet AVEO5 LS 1.6 L4 GAS
- Drain engine coolant.
- Remove electric cooling fans.
- Remove upper radiator hose clamp.
- Disconnect upper and lower radiator hoses from radiator.
- Disconnect s...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Chevrolet AVEO5 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Chevrolet AVEO5 LS 1.6 L4 GAS
To remove power steering pump belt, remove accessory belt in first.
- Rotate tensioner star-nut counterclockwise a...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Chevrolet AVEO5 AUTOMOBILES
Component location diagrams for most 2007 Chevrolet AVEO5 cars and light trucks sold in the U.S. from 1990+.
Headlamp Switch, IP Dimmer Switch, Daytime Running Lamps Module Diagram for 2007 Chevrolet AVEO5 LS 1.6 L4 GAS Components on diagram: |
Seat Belt Assembly Diagram for 2007 Chevrolet AVEO5 LS 1.6 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Chevrolet AVEO5 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Chevrolet AVEO5 cars and light trucks sold in the U.S.
2007 Chevrolet AVEO5 LS 1.6 L4 GAS Wiring Diagram Components on diagram: |
2007 Chevrolet AVEO5 LS 1.6 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Chevrolet AVEO5 AUTOMOBILES
OEM TSB listings for most 2007 Chevrolet AVEO5 cars and light trucks sold in the U.S. from 1985+.
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2007 Chevrolet AVEO5 LS 1.6 L4 GAS Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2007 Chevrolet AVEO5 LS 1.6 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Chevrolet AVEO5 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Chevrolet AVEO5 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Chevrolet AVEO5 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Chevrolet AVEO5 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Chevrolet AVEO5 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet AVEO5 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Chevrolet AVEO5 vehicle. |
Access the Complete guide! |