Auto Parts Search
2005 Subaru Outback CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Subaru REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2005 Subaru Outback AUTOMOBILES
Subaru -> Hydraulic Brake Systems -> Component Replacement -> Dual Proportioning Valve -> Master Cylinder
Vehicle: 2005 Subaru Outback 3.0 H6 GAS
Master Cylinder
- Disconnect brake lines from master cylinder and plug the ends.
- If applicable, disconnect fluid warning switch electrical connector.
- Remove master cylinder retaining nuts and the master cylinder.
- Reverse procedure to install.
- Bleed hydraulic system after completing installation.
Dual Proportioning Valve
Inspect brake line connections at DPV...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Subaru Outback AUTOMOBILES
Subaru -> Component Locations -> B9 Tribeca, 2004-06 Impreza WRX STi, Legacy & Outback & 2005-06 Forester & Impreza
Vehicle: 2005 Subaru Outback 2.5 H4 GAS
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Subaru Outback AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2005 Subaru Outback 3.0 H6 GAS
Wrap metal parts with a cloth or rubber material. Rubber boot may be damaged due to interference with adjacent metal parts during removal.
- Disconnect battery ground cable.
- Place vehicle in neutral.
- Release parking brake.
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove center exhaust pipes bolts and nuts.
- Remove rear exhaust pipe and muffler.
- Remove heat shield cover.
- Place reference mark on front driveline and rear differential flange. Paint is recommended for match marks. Never damage rear driveline shaft flange yoke or companion flange
- Remove...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2005 Subaru Outback AUTOMOBILES
Component Replacement -> Clamp In Type -> Installation -> Removal -> Snap In Type -> Tire Pressure Sensor -> TPMS Control Module
Vehicle: 2005 Subaru Outback 2.5 H4 GAS
Tire Pressure Sensor
Clamp In Type
Removal
- Loosen the lug nuts.
- Raise and support vehicle with jack stands, then remove the wheel and tire assembly.
- Release the air pressure from the tire.
- Using a suitable tire changer, remove the tire from the wheel.
- Remove the screw attaching the tire pressure sensor to the valve stem, Fig. .
Installation
Use a new grommet when installing the tire pressure sensor.
- Align the tire pressure sensor with the valve stem hole, Fig. .
- Install and tighten the tire pressure sensor nut to 72 inch lbs.
- Using a suitable tire changer install the tire to the wheel...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Subaru Outback AUTOMOBILES
Starter, Replace
Vehicle: 2005 Subaru Outback 2.5 H4 GAS
- Disconnect battery ground cable.
- Disconnect solenoid wiring at starter.
- Remo...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 Subaru Outback AUTOMOBILES
Cabin Air Filter Service -> Subaru -> 2005-06 Baja & 2005-09 Legacy & Outback
Vehicle: 2005 Subaru Outback 2.5 H4 GAS
The cabin air filter should be replaced every 12 months or 9,300 miles.
- Remove the instrument panel side cover.
- Remove the glove compartment retaining clips and damper, then the glove compartment, Fig. .
- Remove the glove compartment upper storage bin.
- Through the glove compar...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Subaru Outback AUTOMOBILES
Subaru -> Air Bag Warning Lamp ->
Vehicle: 2005 Subaru Outback 2.5 H4 GAS
The air bag warning lamp, located inside the combination meter, will illuminate in the event of a poor connection or other air bag system fault. When the air bag system is functioning properly, the lamp should go out approximately 8 seconds after the ignition switch ...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Subaru Outback AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2005 Subaru Outback 2.5 H4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at thermostat housing.
- Remove hose from thermostat housing.
- Remove hose from vehicle.
- Reverse proc...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Subaru Outback AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Subaru Outback 3.0 H6 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Subaru Outback AUTOMOBILES
Component location diagrams for most 2005 Subaru Outback cars and light trucks sold in the U.S. from 1990+.
EVAP System Diagram for 2005 Subaru Outback 3.0 H6 GAS Components on diagram: |
Rear Body Harness Connectors Diagram for 2005 Subaru Outback 3.0 H6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Subaru Outback AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Subaru Outback cars and light trucks sold in the U.S.
2005 Subaru Outback 3.0 H6 GAS Wiring Diagram Components on diagram: |
2005 Subaru Outback 3.0 H6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Subaru Outback AUTOMOBILES
OEM TSB listings for most 2005 Subaru Outback cars and light trucks sold in the U.S. from 1985+.
Document: Service Manual Corrections Vehicle: 2005 Subaru Outback 2.5 H4 GAS Auto Systems: |
Document: EVAPORATIVE EMISSION SYSTEM DIAGNOSTIC
INFORMATION Vehicle: 2005 Subaru Outback 2.5 H4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Subaru Outback AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Subaru Outback cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Subaru Outback cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Subaru Outback cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Subaru Outback cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Subaru Outback SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2005 Subaru Outback vehicle. |
Access the Complete guide! |