Auto Parts Search
2005 Jeep Grand Cherokee CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Jeep REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2005 Jeep Grand Cherokee AUTOMOBILES
Disc Brakes -> Parking Brake Service -> Caravan, Town & Country & Voyager -> Grand Cherokee, Liberty & Wrangler -> Park Brake Shoes
Vehicle: 2005 Jeep Grand Cherokee Laredo 4.7 V8 GAS
Caravan, Town & Country & Voyager
Park Brake Shoes
- Set parking brake. Parking brake is set to keep hub/bearing and axle shaft from rotating when loosening hub nut.
- Raise and support vehicle allowing rear suspension to hang free.
- Remove rear wheels.
- Remove cotter pin and nut retainer from stub shaft of outer C/V joint.
- Remove spring washer, hub nut and washer from stub shaft of outer C/V joint.
- Release parking brake.
- Create slack in rear park brake by locking out automatic adjuster as follows:
- Grasp exposed section of front park brake and pull downward on it.
- Install a pair of suitab...
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Jeep Grand Cherokee AUTOMOBILES
DaimlerChrysler Corp./Jeep Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> 2005-06 Grand Cherokee
Vehicle: 2005 Jeep Grand Cherokee Laredo 3.7 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
- Relieve fuel system pressure as outlined under "Fuel System Pressure Relief."
- Loosen cla...
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Jeep Grand Cherokee AUTOMOBILES
DRIVESHAFT, Replace -> Front -> Rear
Vehicle: 2005 Jeep Grand Cherokee Limited 5.7 V8 GAS
Front
- With vehicle in neutral, position vehicle on hoist.
- Mark a line across axle pinion flange, propeller shaft, flange yoke and transfer case for installation reference.
- Support transmission and transmission crossmember.
- Remove propeller shaft from transfer case flange.
- Remove propeller shaft from axle pinion flange.
- Reverse procedure to install, noting the following:
- Align reference marks.
- Torque axle flange bolts to 80 ft. lbs.
- Torque transfer case flange bolts to 24 ft. lbs.
Rear
- With vehicle in neutral, positio...
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2005 Jeep Grand Cherokee AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Trouble Code Identification -> Intermittent & Poor Connections -> Intermittents -> Low Pressure -> Poor Connections -> System Fault -> TPMS Check
Vehicle: 2005 Jeep Grand Cherokee Limited 5.7 V8 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Trouble Code Identification
Refer to Fig. for diagnostic trouble code identification.
Clearing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector), and follow manufacturer's instructions.
TPMS Check
When diagnosing a TPMS problem, first check the TPMS indicator lamp with ignition switch in the On position. From the Off position, turn the ignition key to On and check the TPMS indicator la...
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Jeep Grand Cherokee AUTOMOBILES
Starter, Replace
Vehicle: 2005 Jeep Grand Cherokee Limited 5.7 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- On models with 4WD, remove front drive shaft.
- Remove support brackets bolts at transmission. Pry support bracket slightly to gain access to lower starter mounting bolt.
- On all models, remove starter mounting bolts.
- Move starter motor towards front of vehicle far enough for nose of starter pinion housing to clear housing.
- Do not let starter motor hang from wires.
- Tilt nose downwards and lower starter motor far enough to access ...
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Jeep Grand Cherokee AUTOMOBILES
Chrysler LLC Trucks -> Tire Pressure Monitoring System (TPMS) Warning Indicator -> 2005-09 Grand Cherokee -> Relearn -> Reset
Vehicle: 2005 Jeep Grand Cherokee Limited 5.7 V8 GAS
Reset
The Low Tire Pressure indicator lamp will flash slowly and sound a single tone when tire pressure is low. If tire pressure drops lower, the indicator lamp will flash rapidly and the tone will be continuous. When the tire is inflated to the proper pressure the lamp and tone will turn Off. The vehicle may need to be driven at a speed above 15 MPH for up to 10 minutes for the TPMS to receive this information. If the lamp remains On, a problem in the low tire warning system is present and the low tire warning system must b...
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Jeep Grand Cherokee AUTOMOBILES
Radiator, Replace
Vehicle: 2005 Jeep Grand Cherokee Laredo 3.7 V6 GAS
- Drain radiator coolant into suitable container.
- Remove six upper push pins and front grill.
- Remove two radiator mounting bolts.
- Disconnect transmission cooler lines. Plug lines.
- Disconnect fan control solenoid electrical connector.
- Disconnect power steering cooling line from cooler and filter. Plug line.
- Disconnect upper and lower radiator hoses, then overflow hose.
- Remove air inlet duct at gri...
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Jeep Grand Cherokee AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Jeep Grand Cherokee Limited 5.7 V8 GAS
- Remove air intake tube between intake manifold and air filter.
- Release belt tension by rotating tensioner counterclockwise with suitable wrench on tensioner pulley bolt.
- Rotate belt tensioner until belt can be removed from pull...
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Jeep Grand Cherokee AUTOMOBILES
Component location diagrams for most 2005 Jeep Grand Cherokee cars and light trucks sold in the U.S. from 1990+.
Side Curtain Airbags, Side Impact Sensor, Power Outlet, and Amplifier Diagram for 2005 Jeep Grand Cherokee Limited 4.7 V8 GAS Components on diagram: |
Wheel Speed Sensor, Trailer Tow, and Fuel Pump Module Diagram for 2005 Jeep Grand Cherokee Limited 5.7 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Jeep Grand Cherokee AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Jeep Grand Cherokee cars and light trucks sold in the U.S.
2005 Jeep Grand Cherokee Limited 5.7 V8 GAS Wiring Diagram Components on diagram: |
2005 Jeep Grand Cherokee Limited 5.7 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Jeep Grand Cherokee AUTOMOBILES
OEM TSB listings for most 2005 Jeep Grand Cherokee cars and light trucks sold in the U.S. from 1985+.
Document: Flash: Hesitation Feel Between 38 To 45 MPH Vehicle: 2005 Jeep Grand Cherokee Laredo 4.7 V8 GAS Symptoms: |
Document: Chrome Clad Wheel Adapters For Proper Balancing Vehicle: 2005 Jeep Grand Cherokee Laredo 4.7 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Jeep Grand Cherokee AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Jeep Grand Cherokee cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Jeep Grand Cherokee cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Jeep Grand Cherokee cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Jeep Grand Cherokee cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Jeep Grand Cherokee SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2005 Jeep Grand Cherokee vehicle. |
Access the Complete guide! |