Auto Parts Search
2005 Ford Focus CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Ford REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2005 Ford Focus AUTOMOBILES
Drum Brakes -> Focus -> Inspection
Vehicle: 2005 Ford Focus ZX5 2.0 L4 GAS
- Inspect components for damage and unusual wear.
- Inspect wheel cylinders. Boots which are torn, cut, or heat damaged indicate need for wheel cylinder replacement. Fluid spilling from boot center hole or wetness around wheel cylinder ends indicates cup leakage and need for wheel cylinder replacement. A small amount of fluid is always present and is considered normal, acting as lubricant for cylinder pistons.
- Ins...
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Ford Focus AUTOMOBILES
Ford Motor Co. Passenger Cars -> Fuel Shutoff Switch Location -> 2000-06 Focus
Vehicle: 2005 Ford Focus ZX4 ST 2.3 L4 GAS
The switch is located on...
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Ford Focus AUTOMOBILES
CV AXLE SHAFT, Replace -> Intermediate shaft -> Left side -> Right side
Vehicle: 2005 Ford Focus ZX4 ST 2.3 L4 GAS
Left side
- Loosen left-hand strut and spring assembly top mount nuts by four turns.
- Loosen wheel nuts.
- Loosen wheel hub retaining nut.
- Raise and support vehicle.
- Remove left-hand wheel.
- . Detach left-hand lower arm.
- Remove pinch bolt from ball joint stud. Protect ball joint seat using a soft cloth to prevent damage.
- Detach lower arm ball joint.
- Detach left-hand drive halfshaft from wheel hub by using a commercially available puller. Unscrew and remove hub retaining nut and press out halfshaft stub from wheel hub.
- Support halfshaft. Inner halfshaft joint must not be bent by more than...
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Ford Focus AUTOMOBILES
Starter, Replace
Vehicle: 2005 Ford Focus ZX4 ST 2.3 L4 GAS
- Disconnect battery ground cable.
- Ensure transmission is in Neutral position, then raise and support vehicle.
- Remove terminal nuts and disconnect starter motor wiring.
- Remove mounting nut and disconnect Power Steering Pressure tube brackets from stud bolts.
- Remove starter motor mounting bolts, th...
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 Ford Focus AUTOMOBILES
Cabin Air Filter Service -> Ford Motor Co. -> 2000-07 Focus
Vehicle: 2005 Ford Focus ZX4 2.0 L4 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Position the windshield wipers in the vertical position.
- Open the hood.
- Remove the caps from the righthand side air cowl grille retaining screws.
- Remove the righthand side air cowl grille retaining screws, then the grille.
- Open the service flap, then remove the cabin air filter ...
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Ford Focus AUTOMOBILES
Ford Motor Co. Cars -> Low Coolant Lamp ->
Vehicle: 2005 Ford Focus ZX3 2.0 L4 GAS
The low coolant warning lamp should light whenever the coolant level in the coolant recovery bottle is 1/4 to 3/4 inch or more below the cold full mark. Raise coolant level in recovery bottle to the cold full mark to turn lamp off.
On models equipped with GEM module and low coolant level warning system, t...
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Ford Focus AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2005 Ford Focus ZX4 2.0 L4 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Reposition heater core inlet hose clamp at coolant outlet adapter.
- Remove hose from coolant outlet adapter.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Drain cooling system into a suitable container.
- Reposition heater hose outlet clamp at heater core.
- Disconnect...
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Ford Focus AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Ford Focus ZX3 2.0 L4 GAS
- Raise and support vehicle.
- Remove drive belt cover.
- Loosen bolts on coola...
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Ford Focus AUTOMOBILES
Component location diagrams for most 2005 Ford Focus cars and light trucks sold in the U.S. from 1990+.
Engine Bulkhead Components Diagram for 2005 Ford Focus ZX4 ST 2.3 L4 GAS Components on diagram: |
Vehicle Floor Components Diagram for 2005 Ford Focus ZX4 ST 2.3 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Ford Focus AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Ford Focus cars and light trucks sold in the U.S.
2005 Ford Focus ZXW 2.0 L4 GAS Wiring Diagram Components on diagram: |
2005 Ford Focus ZX4 ST 2.3 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Ford Focus AUTOMOBILES
OEM TSB listings for most 2005 Ford Focus cars and light trucks sold in the U.S. from 1985+.
Document: WHITE FLAKES COMING FROM A/C VENTS - REVISED Vehicle: 2005 Ford Focus ZX3 2.0 L4 GAS Auto Systems: |
Document: ENGINE VIBRATION AT IDLE - REVISED Vehicle: 2005 Ford Focus ZX3 2.0 L4 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Ford Focus AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Ford Focus cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Ford Focus cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Ford Focus cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Ford Focus cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Ford Focus SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2005 Ford Focus vehicle. |
Access the Complete guide! |