Auto Parts Search
2004 GMC Envoy CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GMC REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2004 GMC Envoy AUTOMOBILES
Air Bag System Precautions -> General Motors Corp. -> Arming -> Light Trucks & Vans -> Passenger Cars
Vehicle: 2004 GMC Envoy XUV 4.2 L6 GAS
Passenger Cars
Reverse disarming procedures to arm the Supplemental Restraint System, noting the following:
- Ensure all disconnected SRS electrical connectors are securely connected and routed.
- Install all removed fuses in proper locations.
- From a safe position at sides of or below air bag module, Turn ignition switch to ON position and observe Air Bag or SRS warning lamp.
- On all models except Prizm and 1990 Corvette, warning lamp should flash seven to nine times, then go off.
- On Prizm models, warning lamp should light for six seconds,...
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 GMC Envoy AUTOMOBILES
Power Brake Units -> Delco Brake Booster -> Power Brake Unit, Replace -> Astro, Avalanche, Escalade EXT, Safari, Sierra, Silverado & SSR -> Aztek & Rendezvous -> Blazer, Bravada, Envoy, Jimmy, Rainier & Trailblazer -> Canyon, Colorado, Sonoma & S10 -> Equinox & Torrent -> Escalade, HHR, Suburban, Tahoe & Yukon -> Express & Savana -> Hummer H2 -> Hummer H3 -> Montana, Silhouette & Venture -> Relay, Terraza, SV6 & Uplander -> SRX -> Vue
Vehicle: 2004 GMC Envoy XL 5.3 V8 GAS
Aztek & Rendezvous
- Remove coolant reservoir, then relieve fuel system pressure as follows:
- Loosen fuel filler cap to discharge tank pressure.
- Connect fuel pressure gauge tool No. J-34730-1A, or equivalent, to fuel pressure connection. Wrap shop towel around connection while connecting fuel pressure gauge in order to avoid fuel spillage.
- Install bleed hose into an approved container and open valve in order to bleed fuel system pressure.
- Drain any fuel remaining in fuel pressure gauge into suitable container.
- Remove cruise control cable from module, then disconnect electrical ...
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2004 GMC Envoy AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Pressure Relief -> Except Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Tracker & Uplander -> Engine Fuel Pressure Service Port -> Engines Less Fuel Pressure Service Port
Vehicle: 2004 GMC Envoy 4.2 L6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
Engines Less Fuel Pressure ...
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2004 GMC Envoy AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2004 GMC Envoy 4.2 L6 GAS
- Unlock steering column so that steering linkage is free to move.
- Raise the vehicle. Support vehicle with suitable safety stands.
- Remove front tire and wheel assemblies.
- In order to prevent drive axle from turning, insert a drift through brake caliper and into one of the rotor vanes.
- Remove axle nut and washer.
- Remove drift from brake rotor.
- Remove front brake rotors and support caliper with piece of wire in order to prevent damage to brake hose.
- Remove brackets from upper control arm holding both ABS wire and brake hose.
- Remove ABS bracket located on top of upper control arm ball...
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2004 GMC Envoy AUTOMOBILES
Alternator, Replace
Vehicle: 2004 GMC Envoy XL 4.2 L6 GAS
- Disconnect battery ground cable.
- Remove air inlet duct.
- Remove heater hose brace bolt from rear of alternator.
- Disconnect alternator electrical connectors.
- Remove accessory drive belt.
- Remove alternator mounti...
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2004 GMC Envoy AUTOMOBILES
General Motors Corp./Saturn Trucks -> StabiliTrak Control System Warning Lamp ->
Vehicle: 2004 GMC Envoy XL 5.3 V8 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned On as a bulb check. If the warning...
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2004 GMC Envoy AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2004 GMC Envoy XUV 4.2 L6 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from thermostat housing.
- Remove radiator outlet hose from thermostat housing and from vehicle.
- Reverse procedure to in...
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2004 GMC Envoy AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2004 GMC Envoy XL 5.3 V8 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from drive belt.
- Remove t...
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2004 GMC Envoy AUTOMOBILES
Component location diagrams for most 2004 GMC Envoy cars and light trucks sold in the U.S. from 1990+.
Vehicle Speed Sensor Diagram for 2004 GMC Envoy XL 4.2 L6 GAS Components on diagram: |
I/P Carrier,Cowl Side Diagram for 2004 GMC Envoy 4.2 L6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2004 GMC Envoy AUTOMOBILES
OEM drawn wiring diagrams for most 2004 GMC Envoy cars and light trucks sold in the U.S.
2004 GMC Envoy XUV 4.2 L6 GAS Wiring Diagram Components on diagram: |
2004 GMC Envoy 4.2 L6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2004 GMC Envoy AUTOMOBILES
OEM TSB listings for most 2004 GMC Envoy cars and light trucks sold in the U.S. from 1985+.
Document: Engine Rattle Noise after R And R of the Crankshaft Balancer -Inspect Bolt Torque Vehicle: 2004 GMC Envoy 4.2 L6 GAS Symptoms: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2004 GMC Envoy 4.2 L6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2004 GMC Envoy AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2004 GMC Envoy cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2004 GMC Envoy cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2004 GMC Envoy cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2004 GMC Envoy cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2004 GMC Envoy SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2004 GMC Envoy vehicle. |
Access the Complete guide! |