Auto Parts Search
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2002 Pontiac Firebird car and truck
repair procedures including Pontiac engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your 2002 Pontiac Firebird automobile. Try the Automotix DIY solution today!
We have info for following modifications of 2002 Pontiac Firebird
- 2002 Pontiac Firebird 3.8 V6 GAS, CID:231, Fuel Injection, Aspiration:231, Engine VIN:, Desg:K
- 2002 Pontiac Firebird Trans AM 5.7 V8 GAS, CID:350, Fuel Injection, Aspiration:350, Engine VIN:, Desg:G
- 2002 Pontiac Firebird Formula 5.7 V8 GAS, CID:350, Fuel Injection, Aspiration:350, Engine VIN:, Desg:G
A/C & HEATER SERVICE PROCEDURES FOR 2002 Pontiac Firebird AUTOMOBILES
Air Conditioner and Heater Service Includes module configuration procedures, general service, maintenance, automatic temperature control, compressor services, electric cooling fans, vacuum diagrams, specifications, and manual air conditioning and heater diagnostics and replacement procedures for domestic and imported 2002 Pontiac Firebird cars and light trucks from 1990+
General Service Domestic Vehicles -> 2001-02 -> Pressure Gauge Indication
Vehicle: 2002 Pontiac Firebird Formula 5.7 V8 GAS
Due to the different types of models and systems, the following typical pressure gauge indications should be used as a guide only as shown in Fig. . Refer to the "Performance Tests" or "System Pressure Check" for the particular model being tested. When indications other than normal are encountered, these typical indication charts will assist in diagnosing the refrigerant system. It should be noted that pressures may vary slightly above or below due to changes in ambient temperature and relative humidity.
CLICK HERE TO GET FULL ACCESS TO 2002 Pontiac Firebird A/C & HEATER SERVICE PROCEDURES
A/C & HEATER SERVICE PROCEDURES FOR 2002 Pontiac Firebird AUTOMOBILES
Air Conditioner and Heater Service Includes module configuration procedures, general service, maintenance, automatic temperature control, compressor services, electric cooling fans, vacuum diagrams, specifications, and manual air conditioning and heater diagnostics and replacement procedures for domestic and imported 2002 Pontiac Firebird cars and light trucks from 1990+
Air Bag System Precautions -> General Motors Corp. -> Disarming -> 1990 -> 1990-93 -> 1990-95 -> 1990-97 -> 1991 -> 1991-93 -> 1991-94 -> 1991-95 -> 1992-93 -> 1992-99 -> 1993-2002 -> 1993-94 -> 1993-98 -> 1994 -> 1994-2002 -> 1994-95 -> 1994-96 -> 1994-98 -> 1995-2002 -> 1995-96 -> 1995-97 -> 1995-98 -> 1995-99 -> 1996 -> 1996-2001 -> 1996-97 -> 1997 -> 1997-2002 -> 1997-98 -> 1997-99 -> 1998-2000 -> 1998-2002 -> 1998-99 -> 1999 -> 1999-2000 -> 1999-2001 -> 1999-2002 -> 2000-02 -> 2001-02 -> 2002 -> 2003 -> 2003-04 -> 2003-04 Except Malibu Maxx -> Achieva & Skylark -> Alero -> Astro & Safari -> Aurora -> Avalanche -> Aveo -> Aztek & Rendezvous -> Beretta & Corsica -> Blazer, Jimmy, Sonoma & S-10 -> Bonneville, Eighty-Eight, LeSabre, LSS, Ninety-Eight & Regency -> Bravada, Envoy, Rainier, SSR & TrailBlazer -> C/K Series -> Camaro & Firebird -> Canyon & Colorado -> Caprice, Custom Cruiser & Roadmaster -> Catera -> Cavalier & Sunfire -> Century -> Corvette -> Coupe -> CTS -> Cutlass -> Cutlass Ciera & Cruiser -> Cutlass Supreme -> DeVille -> Eldorado -> Escalade -> Express, G Series & Savana -> Fleetwood -> Grand Am -> Grand Prix & Intrigue -> Impala -> ION -> L-Series -> Light Trucks & Vans -> Lumina -> Lumina APV, Montana, Silhouette, Trans Sport & Venture -> Malibu -> Malibu Maxx -> Metro -> Monte Carlo -> Park Avenue -> Passenger Cars -> Prizm -> Reatta, Toronado & Trofeo -> Regal -> Riviera -> S-Series -> Sedan -> Seville -> Sierra & Silverado -> SRX -> Storm -> Suburban, Tahoe, Yukon & Yukon XL -> Tracker -> Vibe -> VUE -> XLR -> Zone 1 -> Zone 10 -> Zone 12 -> Zone 2 -> Zone 3 -> Zone 4 -> Zone 5 -> Zone 6 -> Zone 7 -> Zone 8 -> Zone 9 -> Zones 1 & 7 -> Zones 2 & 6 -> Zones 5 & 9 -> Zones 7 & 9
Vehicle: 2002 Pontiac Firebird Formula 5.7 V8 GAS
Passenger Cars
The Sensing and Diagnostic Module (SDM) can maintain enough voltage to cause air bag deployment for up to 10 minutes after the ignition is turned Off and the battery is disconnected. Servicing the Supplemental air bag (SIR) system during this period may result in accidental deployment and personal injury.
Achieva & Skylark
1994-96
- Ensure front wheels are in straight-ahead position.
- Turn ignition switch to LOCK position.
- Remove AIR BAG fuse from fuse block.
- On 1995 models, remove lefthand sound insulator panel to ac...
CLICK HERE TO GET FULL ACCESS TO 2002 Pontiac Firebird A/C & HEATER SERVICE PROCEDURES
A/C & HEATER SERVICE PROCEDURES FOR 2002 Pontiac Firebird AUTOMOBILES
Air Conditioner and Heater Service Includes module configuration procedures, general service, maintenance, automatic temperature control, compressor services, electric cooling fans, vacuum diagrams, specifications, and manual air conditioning and heater diagnostics and replacement procedures for domestic and imported 2002 Pontiac Firebird cars and light trucks from 1990+
Electric Cooling Fans -> Passenger Cars Except Saturn -> Component Replacement -> 2002 Century & Regal -> 3.5L Engine -> 4.0L Engine -> Alero, Grand Am & Malibu -> Aurora -> Bonneville & LeSabre -> Camaro & Firebird -> Catera -> Cavalier & Sunfire -> Corvette -> DeVille -> Eldorado -> Grand Prix & 2001 Century & Regal -> Impala -> Intrigue -> Lumina & Monte Carlo -> Metro -> Park Avenue -> Prizm -> Seville
Vehicle: 2002 Pontiac Firebird Trans AM 5.7 V8 GAS
Alero, Grand Am & Malibu
- Remove bolt retaining A/C line.
- Remove air deflector shield.
- Remove electrical harness from retainers.
- Disconnect electrical connector.
- Remove upper fan bolts.
- Raise and support vehicle, then remove lower closeout panel.
- Remove lower fan bolts.
- Remove fan from shroud.
- Remove shroud from radiator.
- Reverse procedure to install.
Aurora
3.5L Engine
- Remove upper tie bar.
- Disconnect wiring harness electrical connector from cooling fan motors.
- Remove clips at...
CLICK HERE TO GET FULL ACCESS TO 2002 Pontiac Firebird A/C & HEATER SERVICE PROCEDURES
A/C & HEATER SERVICE PROCEDURES FOR 2002 Pontiac Firebird AUTOMOBILES
Air Conditioner and Heater Service Includes module configuration procedures, general service, maintenance, automatic temperature control, compressor services, electric cooling fans, vacuum diagrams, specifications, and manual air conditioning and heater diagnostics and replacement procedures for domestic and imported 2002 Pontiac Firebird cars and light trucks from 1990+
General Service Domestic Vehicles -> 2001-02 -> Refrigerant Recovery
Vehicle: 2002 Pontiac Firebird 3.8 V6 GAS
R-134a systems require the use of special service equipment designed specifically for R-134a systems. R-12 servicing equipment cannot be used on R-134a systems.
R-12 recovery stations cannot be used on R-134a systems. A separate recovery station must be used on R-134a systems. The refrigerants are not compatible and will contaminate the R-12 recovery station.
The use of refrigerant recovery and recycling stations allows the recovery and reuse of refrigerant after contaminants and moisture have been removed.
When using a recovery or recycling station...
CLICK HERE TO GET FULL ACCESS TO 2002 Pontiac Firebird A/C & HEATER SERVICE PROCEDURES
A/C & HEATER SERVICE PROCEDURES FOR 2002 Pontiac Firebird AUTOMOBILES
Air Conditioner and Heater Service Includes module configuration procedures, general service, maintenance, automatic temperature control, compressor services, electric cooling fans, vacuum diagrams, specifications, and manual air conditioning and heater diagnostics and replacement procedures for domestic and imported 2002 Pontiac Firebird cars and light trucks from 1990+
Compressor Service -> Harrison V7 Variable Displacement Compressor -> Shaft Seal, Replace -> Installation -> Removal
Vehicle: 2002 Pontiac Firebird Formula 5.7 V8 GAS
The shaft seal should not be replaced if only small amounts of oil are noted on adjacent surfaces. The shaft seal should only be replaced if a large amount of sprayed oil is observed, and then only after actual refrigerant leakage is found using an approved leak test procedure.
Removal
- Recover refrigerant as outlined under , then remove compressor drive belt.
- Reposition compressor, as needed, to gain access to clutch assembly and seal, or remove compressor and mount in suitable holding fixture.
- Remove clutch plate and hub assembly as outlined under "Compressor Clutch Service."
- Remo...
CLICK HERE TO GET FULL ACCESS TO 2002 Pontiac Firebird A/C & HEATER SERVICE PROCEDURES
A/C & HEATER SERVICE PROCEDURES FOR 2002 Pontiac Firebird AUTOMOBILES
Air Conditioner and Heater Service Includes module configuration procedures, general service, maintenance, automatic temperature control, compressor services, electric cooling fans, vacuum diagrams, specifications, and manual air conditioning and heater diagnostics and replacement procedures for domestic and imported 2002 Pontiac Firebird cars and light trucks from 1990+
General Service Domestic Vehicles -> 2001-02 -> Oil Charge -> Alero & Malibu -> Bonneville, LeSabre & Park Avenue -> Camaro, Century & Firebird -> Caravan, Town & Country & Voyager -> Catera -> Cavalier & Sunfire -> Cherokee, Dakota, Full Size Pickups, Grand Cherokee & Wrangler -> Corvette -> DaimlerChrysler Corp. -> DeVille & Seville -> Eldorado -> Except Lincoln LS -> Except Tracker -> Ford Motor Company -> Full Size & Ram Vans -> General Motors Corp. -> Geo Tracker -> Grand Prix, Impala, Intrigue, Lumina, Monte Carlo & Regal -> L-Series -> Liberty -> Light Trucks & Vans -> Lincoln LS -> Metro -> Passenger Cars -> Prizm -> PT Cruiser -> S-Series -> Saturn -> VUE
Vehicle: 2002 Pontiac Firebird Trans AM 5.7 V8 GAS
DaimlerChrysler Corp.
Passenger Cars
Before installing replacement compressor, drain oil from replacement and failed compressors (drain oil from suction port). Add same amount of oil to replacement compressor as drained from failed compressor.
Remove defective components. Add the proper amount of oil to each replacement component. Most recovery/recycling equipment will measure the amount of oil being removed. This is the amount of oil to be added back to the system, follow manufactures instructions provided with the recovery/recycling station.
When other ai...
CLICK HERE TO GET FULL ACCESS TO 2002 Pontiac Firebird A/C & HEATER SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2002 Pontiac Firebird vehicle.
|
| Access the Complete guide! |
