Auto Parts Search
We have info for following modifications of 2002 Chevrolet Tracker
- 2002 Chevrolet Tracker 2.0 L4 GAS, CID:122, Fuel Injection, Aspiration:122, Engine VIN:, Desg:C
- 2002 Chevrolet Tracker 2.5 V6 GAS, CC:2500, Fuel Injection, Engine VIN:, Desg:4
BRAKE SERVICE PROCEDURES FOR 2002 Chevrolet Tracker AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Chevrolet Tracker cars and light trucks from 1990+.
Drum Brakes -> Adjustments -> Astro, Bravada, S & T Series & Safari -> Automatic Apply Parking Brakes -> Aztek, Montana, Rendezvous, Silhouette, Trans Sport, Vue & Venture -> C & K Series -> Control Rod -> Express, Savana & P Series -> Lever Type -> Manual Parking Brake -> Optional Method -> Pedal Type -> Propeller Shaft Type -> Service Brake -> Standard Method -> Tracker
Vehicle: 2002 Chevrolet Tracker 2.0 L4 GAS
Service Brake
These brakes have self-adjusting shoe mechanisms that ensure correct lining-to-drum clearances at all times. The automatic adjusters operate only when the brakes are applied as the vehicle is moving rearward or when the vehicle comes to an uphill stop.
Although the brakes are self-adjusting, an initial adjustment is required after the brake shoes have been relined or replaced, or when the length of the adjusting screw has been changed during some other service operation.
Frequent usage of an automatic transmission forward range to halt reverse vehicle motion may prevent t...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tracker BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Chevrolet Tracker AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Chevrolet Tracker cars and light trucks from 1990+.
Hydraulic Brake Systems -> Adjustments -> Height Sensing Proportioning Valve
Vehicle: 2002 Chevrolet Tracker 2.5 V6 GAS
Height Sensing Proportioning Valve
The height sensing proportioning valve must be adjusted whenever the valve and/or linkage is disassembled or removed for service. In addition, adjustment should be inspected if excessive front wheel lock-up is experienced with a lower than desired brake application rate when vehicle is at or near maximum GVWR.
- Raise and support vehicle, leave wheels on and allow axle to hang freely.
- Remove lever retaining nut and disconnect lever from valve shaft,. Fig. .
- Rotate valve shaft to permit installation of correct adjustment gauge,. Fig. , ensure D shaped hol...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tracker BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Chevrolet Tracker AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Chevrolet Tracker cars and light trucks from 1990+.
Power Brake Units -> Tracker Brake Booster -> Power Brake Unit Service
Vehicle: 2002 Chevrolet Tracker 2.5 V6 GAS
The power brake unit is n...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tracker BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Chevrolet Tracker AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Chevrolet Tracker cars and light trucks from 1990+.
Disc Brakes -> Tokico Disc Brakes -> Precautions -> Brake Disc Service -> Brake Lines & Linings -> Brake Roughness -> General
Vehicle: 2002 Chevrolet Tracker 2.0 L4 GAS
Brake Lines & Linings
Remove one of the front wheels and inspect the brake disc, caliper and linings.
Do not allow any oil or grease on the linings. It is recommended that linings be replaced in sets when worn or damaged.
If the caliper is cracked or fluid leakage through the casting is evident, it must be replaced as a unit.
Brake Roughness
The most common cause of brake chatter on disc brakes is a variation in thickness of the disc. If roughness or vibration is encountered during highway operation or if pedal pumping is experienced at low speeds, the disc may have excessive thickness v...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tracker BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Chevrolet Tracker AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Chevrolet Tracker cars and light trucks from 1990+.
Disc Brakes -> Tokico Disc Brakes -> Caliper Service -> Assemble -> Disassemble -> Inspection -> Installation -> Removal
Vehicle: 2002 Chevrolet Tracker 2.5 V6 GAS
Removal
- Raise and support vehicle.
- Remove tire and wheel assembly.
- Remove brake hose mounting bolt from caliper.
- Remove mounting bolts and caliper.
Inspection
Should it become required to remove the caliper for installation of new components, clean components in denatured alcohol, wipe dry using lint-free cloths. Blow out drilled passages and holes using compressed air. Inspect dust boots for punctures or tears. If punctures or tears are evident, new boots should be installed upon assembly.
Inspect piston bores in both housings for scoring or pitting. Bores that show light scratches or...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tracker BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Chevrolet Tracker AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2002 Chevrolet Tracker cars and light trucks from 1990+.
Power Brake Units -> Tracker Brake Booster -> Description
Vehicle: 2002 Chevrolet Tracker 2.5 V6 GAS
Vacuum assist units are similar in operation, using vacuum applied to a diaphragm or piston in opposition to atmospheric pressure in order to increase the force applied to the master cylinder piston. However, two types of vacuum assist assemblies are used, the air suspended type and the vacuum suspended type. Air suspended units are under atmospheric pressure until the brakes are applied, then engine vacuum is admitted causing the piston or diaphragm to move and apply force to the master cyl...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Tracker BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2002 Chevrolet Tracker vehicle. |
Access the Complete guide! |