Auto Parts Search
2000 GMC Yukon XL 1500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GMC REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
General Service Domestic Vehicles -> 1998-2000 -> Pressure Gauge Indication
Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS
Due to the different types of models and systems, the following typical pressure gauge indications should be used as a guide only as shown in Fig. . Refer to the "Performance Tests" or "System Pressure Check" for the particular model being tested. When indications other than normal are encountered, these typical indication charts will assist in diagnosing the refrigerant system. It should be noted that pressures may vary slightly above or below due to changes in ambient temperature and relative humidity.
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
Disc Brakes -> Delco Dual Piston Sliding Caliper -> Precautions -> Brake Disc Service -> Brake Lines & Linings -> Brake Roughness -> General
Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS
Brake Lines & Linings
Remove one of the front wheels and inspect the brake disc, caliper and linings.
Do not allow any oil or grease on the linings. It is recommended that linings be replaced in sets when worn or damaged.
If the caliper is cracked or fluid leakage through the casting is evident, it must be replaced as a unit.
Brake Roughness
The most common cause of brake chatter on disc brakes is a variation in thickness of the disc. If roughness or vibration is encountered during highway operation or if pedal pumping is experienced at low speeds, the disc may have excessive thickness v...
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Pressure Relief -> Except Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Tracker & Uplander -> Engine Fuel Pressure Service Port -> Engines Less Fuel Pressure Service Port
Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
Engines Less Fuel Pressure ...
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
DRIVESHAFT, Replace -> Front -> Rear
Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS
Front
Before disassembly, observe and accurately reference mark all driveline components relative to the propeller shaft and axles. These items include propeller shafts, wheel drive shafts, pinion flanges, and output shafts.
Assemble all components in the exact relationship to each other as they were prior to removal. Observe all published specifications and torque values, and any measurements obtained prior to disassembly.
- Raise and support vehicle.
- Remove transfer case shield, if equipped.
- If equipped with double clamp style boot, remove clamp at transfer case by prying up expo...
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
Starter, Replace
Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Disconnect starter solenoid electrical connectors.
- Remove starter motor mounting bolts, washers, shims, then starter motor from vehicle.
- Reverse proced...
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
General Motors Corp./Saturn Trucks -> Low Coolant Lamp ->
Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS
This lamp should light when engine coolant level in the radiator drops below a predetermined le...
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from water pump.
- Remove radiator outlet hose from water pump and from vehicle.
- Reverse procedure to install.
Upper
- Drain co...
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
Component location diagrams for most 2000 GMC Yukon XL 1500 cars and light trucks sold in the U.S. from 1990+.
Transmission Components Diagram for 2000 GMC Yukon XL 1500 5.3 V8 GAS Components on diagram: |
Variable Effort Steering Diagram for 2000 GMC Yukon XL 1500 5.3 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
OEM drawn wiring diagrams for most 2000 GMC Yukon XL 1500 cars and light trucks sold in the U.S.
2000 GMC Yukon XL 1500 5.3 V8 GAS Wiring Diagram Components on diagram: |
2000 GMC Yukon XL 1500 5.3 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
OEM TSB listings for most 2000 GMC Yukon XL 1500 cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2000 GMC Yukon XL 1500 5.3 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2000 GMC Yukon XL 1500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2000 GMC Yukon XL 1500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2000 GMC Yukon XL 1500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2000 GMC Yukon XL 1500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2000 GMC Yukon XL 1500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2000 GMC Yukon XL 1500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2000 GMC Yukon XL 1500 vehicle. |
Access the Complete guide! |