Auto Parts Search
1999 Pontiac Grand AM CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1999 Pontiac Grand AM AUTOMOBILES
Component Replacement & Adjustment -> Achieva, Alero, Cutlass, Grand Am, Malibu & Skylark -> Water Pump, Replace -> 2.4L Engine -> 3.1L & 3.4L Engines
Vehicle: 1999 Pontiac Grand AM 2.4 L4 GAS
2.4L Engine
- Drain cooling system into suitable container, then disconnect heater hose from thermostat housing.
- Disconnect electrical connector from oxygen sensor.
- Remove upper and lower exhaust manifold heat shields.
- Remove bolt attaching exhaust manifold brace to exhaust manifold.
- Loosen exhaust manifold to exhaust pipe spring loaded bolts using a 13mm wrench.
- Remove radiator outlet pipe to water pump cover bolts.
- Raise and support vehicle.
- Remove manifold to exhaust pipe spring loaded nuts.
- Pull down and back on exhaust...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Pontiac Grand AM AUTOMOBILES
Drum Brakes -> Type 5 -> Brake Service -> Installation -> Removal
Vehicle: 1999 Pontiac Grand AM 3.4 V6 GAS
Removal
- Raise and support vehicle.
- Mark relationship of wheel to axle, then remove wheel and tire assembly.
- Remove brake drum. If drum is difficult to remove, proceed as follows:
- Ensure parking brake is released.
- Back off parking brake cable adjustment.
- Remove access hole plug from backing plate, insert screwdriver through hole and push parking brake lever off its stop.
- Insert punch through hole in splash shield Fig. , tap on punch to loosen drum, then remove drum.
- Remove actuator spring using brake tool No. J-38400, or equivalent to pry loop end of spring from adjuster actuator, Fig. . D...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1999 Pontiac Grand AM AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Filter Scheduled Maintenance -> 1980-06 Gasoline Engine Models Except Catera, LeMans (1988-93) Metro, Nova (1985-88), Saturn & Sprint -> Normal Service -> Severe Service
Vehicle: 1999 Pontiac Grand AM 2.4 L4 GAS
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1999 Pontiac Grand AM AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 1999 Pontiac Grand AM 2.4 L4 GAS
- Raise and suitably support vehicle.
- Remove wheel and tire.
- Remove stabilizer shaft link.
- Remove front wheel drive shaft nut. Insert a drift or a flat-bladed tool into caliper and rotor to prevent rotor from turning.
- Disconnect outer tie rod assembly from steering knuckle.
- Separate ball joint from steering knuckle. Caution: Do not attempt to move vehicle with drive axle(s) removed from wheel bearing. Wheel(s) could fall off, dropping vehicle to ground and causing personal injury or damage to vehicle.
- Separate front wheel drive axle from front wheel drive shaft bearing using a su...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 1999 Pontiac Grand AM AUTOMOBILES
Description
Vehicle: 1999 Pontiac Grand AM 2.4 L4 GAS
The TPMS (Tire Pressure Monitor System) alerts the driver when a large change in the pressure of one tire exists. The system detects a tire pressure condition while the vehicle is in motion, once a tire pressure cond...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1999 Pontiac Grand AM AUTOMOBILES
Starter, Replace
Vehicle: 1999 Pontiac Grand AM 2.4 L4 GAS
- Disconnect battery ground cable.
- Remove air inlet duct from throttle body.
- Remove starter upper mounting bolt.
- Raise and support vehicle.
- Remove shrouding and closeout panels.
- Remove starter lower mounting bolt.
- Position engine wiring harness aside.
- Move ...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1999 Pontiac Grand AM AUTOMOBILES
General Motors Corp./Saturn Cars -> Anti-Lock Warning Lamp ->
Vehicle: 1999 Pontiac Grand AM 3.4 V6 GAS
This lamp should light when the ignition is turned On. The lamp may light for as long as 30 seconds as a bulb and system inspection. If lamp remains lit or lights while operating the vehicle, a fault condition in the anti-lock brake system is indicated. When lamp is lit, turn ignition Off, then restart engine. If l...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1999 Pontiac Grand AM AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 1999 Pontiac Grand AM 2.4 L4 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition inlet heater hose clamp from heater core pipe.
- Remove hose from heater core.
- Reposition heater hose clamp from inlet port of engine.
- Remove inlet heater hose from inlet port of engine.
- Remove hose from vehicle.
- Reverse procedure to ...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1999 Pontiac Grand AM AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1999 Pontiac Grand AM 3.4 V6 GAS
- Support engine with suitable wooden block and suitable floor jack positioned below oil pan.
- Remove cruise control module.
- Remove engine mount to bracket support bo...
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1999 Pontiac Grand AM AUTOMOBILES
Component location diagrams for most 1999 Pontiac Grand AM cars and light trucks sold in the U.S. from 1990+.
Brake Components Diagram for 1999 Pontiac Grand AM 2.4 L4 GAS Components on diagram: |
Body Components Diagram for 1999 Pontiac Grand AM 3.4 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1999 Pontiac Grand AM AUTOMOBILES
OEM drawn wiring diagrams for most 1999 Pontiac Grand AM cars and light trucks sold in the U.S.
1999 Pontiac Grand AM 2.4 L4 GAS Wiring Diagram Components on diagram: |
1999 Pontiac Grand AM 2.4 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1999 Pontiac Grand AM AUTOMOBILES
OEM TSB listings for most 1999 Pontiac Grand AM cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 1999 Pontiac Grand AM 2.4 L4 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 1999 Pontiac Grand AM 2.4 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1999 Pontiac Grand AM AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1999 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1999 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1999 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1999 Pontiac Grand AM cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1999 Pontiac Grand AM SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1999 Pontiac Grand AM vehicle. |
Access the Complete guide! |