Auto Parts Search
We have info for following modifications of 1997 Toyota RAV4
- 1997 Toyota RAV4 2.0 L4 GAS, CC:1998, Fuel Injection, Engine VIN:, Desg:P
- 1997 Toyota RAV4 2-DOOR 2.0 L4 GAS, CC:1998, Fuel Injection, Engine VIN:, Desg:P
BRAKE SERVICE PROCEDURES FOR 1997 Toyota RAV4 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Toyota RAV4 cars and light trucks from 1990+.
Disc Brakes -> Front Disc Brakes -> Caliper Service -> 2WD -> 4Runner -> Avalon, Camry, Camry Solara, Corolla, Celica, Highlander, MR2 & Sienna -> Echo & RAV4 -> Land Cruiser -> Overhaul -> Replace -> Sequoia & Tundra -> Supra -> T100 -> Tacoma -> Tercel
Vehicle: 1997 Toyota RAV4 2.0 L4 GAS
Avalon, Camry, Camry Solara, Corolla, Celica, Highlander, MR2 & Sienna
Replace
- Raise and support vehicle and remove front wheel.
- Remove union bolt and disconnect brake hose. Use suitable container to catch brake fluid.
- Remove caliper, Figs. through .
- Remove anti-squeal shims and brake pad wear indicator plates.
- Remove support plates.
- Reverse procedure to install.
Overhaul
- Remove caliper.
- Remove the following parts:
- Caliper slide bushings.
- Dust boots.
- Collars.
- Using screwdriver, remove caliper boot set ring and boot.
- Place suitable rag between caliper and piston and using compressed air, remov...
CLICK HERE TO GET FULL ACCESS TO 1997 Toyota RAV4 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Toyota RAV4 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Toyota RAV4 cars and light trucks from 1990+.
Drum Brakes -> Adjustments -> 2WD -> 4WD -> Camry, Camry Solara, Celica, Corolla, Echo & Tercel -> Highlander -> Land Cruiser & 4Runner -> Parking Brake -> Tacoma & T100 -> Tundra
Vehicle: 1997 Toyota RAV4 2-DOOR 2.0 L4 GAS
Parking Brake
Camry, Camry Solara, Celica, Corolla, Echo & Tercel
- Apply parking brake and count number of notches on parking brake sector. Specified number of notches should be as follows:
- Camry, Camry Solara, Corolla, Echo and Tercel sedan, 5-8 clicks.
- Celica, 4-7 clicks.
- Tercel wagons, 6-8 clicks.
- On all models, remove console box.
- Loosen locknut and turn adjustment screw until lever travel is correct.
- Tighten locknut and install console.
Highlander
- Slowly press parking brake pedal all the way down and count number of clicks. If parking brake pedal does not click 5-7 times, proceed to next ...
CLICK HERE TO GET FULL ACCESS TO 1997 Toyota RAV4 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Toyota RAV4 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Toyota RAV4 cars and light trucks from 1990+.
Anti-lock Brakes -> Diagnosis & Testing -> 1997-2000 4RUNNER -> 1997-2000 RAV4 -> 1997-2001 CAMRY W/BOSCH ABS -> 1997-2001 CAMRY W/NIPPONDENSO ABS -> 1997-2001 CAMRY W/TRAC -> 1998-2000 SIENNA LESS VSC -> 2001-02 4RUNNER -> 2001-02 RAV4 -> 2001-02 SIENNA LESS VSC -> 2002 CAMRY W/ABS, BA, TRAC & VSC -> 2002 CAMRY W/BOSCH ABS -> 2002 CAMRY W/DENSO ABS -> 4Runner -> ABS Warning Lamp -> Accessing Diagnostic Trouble Codes -> Anti-Lock Brake System (ABS) -> Avalon -> AVALON LESS TRAC -> AVALON W/TRAC -> Avalon, Camry, Celica, Corolla, Echo, MR2, RAV4, Paseo, Sienna, Supra & Tercel -> Brake Actuator -> Camry -> Camry Solara -> CAMRY SOLARA LESS TRAC -> CAMRY SOLARA W/TRAC -> CELICA -> Clearing Diagnostic Trouble Codes -> Component Testing -> Corolla -> Diagnostic Tests -> Diagnostic Trouble Code Interpretation -> Echo -> HIGHLANDER W/ABS, BA, TRAC & VSC -> HIGHLANDER W/BA & ABS -> Land Cruiser -> LAND CRUISER LESS VSC -> LAND CRUISER w/VSC -> Land Cruiser, Previa, Tacoma, T100 & 4Runner -> Less Toyota Hand Held Tester -> Less Toyota Hand-Held Tester -> MR2 -> PASEO -> Previa -> RAV4 -> Sequoia -> Sequoia & Tundra -> Sienna -> SIENNA W/VSC -> Speed Sensor -> Stop Lamp Switch -> Supra -> SUPRA LESS TRAC -> SUPRA W/TRAC -> System Testing -> T100 -> Tacoma -> Tc Terminal -> Tercel -> Traction Control (TRAC) Warning Lamp -> Ts Terminal -> Tundra -> Vehicle Skid Control (VSC) Warning Lamp -> Wiring Diagrams -> With Toyota Hand Held Tester -> With Toyota Hand-Held Tester
Vehicle: 1997 Toyota RAV4 2-DOOR 2.0 L4 GAS
Accessing Diagnostic Trouble Codes
Less Toyota Hand-Held Tester
- On Land Cruiser models, ensure center differential is free.
- On all models, turn ignition switch to On position.
- Disconnect short pin from Data Link Connector 1 (DLC1).
- Connect terminals Tc and E1 or CG of DLC1 or DLC3 using tool No. 09843-18020, or equivalent, Figs. through .
- Read and record number of times ANTI-LOCK warning lamp flashes.
- If system is operating properly, (no faults) warning lamp will blink once every .25 seconds.
- Connect actuator check connector and ensure proper operation.
With Toyota Hand-Held Tester
- O...
CLICK HERE TO GET FULL ACCESS TO 1997 Toyota RAV4 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Toyota RAV4 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Toyota RAV4 cars and light trucks from 1990+.
Hydraulic Brake Systems -> Component Replacement -> Except Land Cruiser & 4Runner -> Except Sienna -> Land Cruiser & 4Runner -> Master Cylinder -> Models w/Load Sensing Proportioning Valve (LSPV) -> Models w/Proportioning & Bypass Valve (P-BV) -> Proportioning Valve -> Sienna -> Wheel Cylinders
Vehicle: 1997 Toyota RAV4 2-DOOR 2.0 L4 GAS
Master Cylinder
Except Sienna
- Remove brake fluid with syringe.
- On RAV4 models, remove air cleaner cover with air cleaner hose.
- On all models, label and disconnect brake lines using line wrench 09751-36011, 09023-00100, or equivalent. Cap brake lines from master cylinder.
- Disconnect wire connector from brake pressure switch and then disconnect level warning switch connector, if equipped.
- Remove master cylinder to brake unit attaching nuts, then remove master cylinder, wire clamp, gasket and 3-way union, as needed.
- Reverse procedure to install. Bleed brake system.
Sienna
- Remove air c...
CLICK HERE TO GET FULL ACCESS TO 1997 Toyota RAV4 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Toyota RAV4 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Toyota RAV4 cars and light trucks from 1990+.
Anti-lock Brakes -> Precautions -> Audio Coded Anti-Theft System -> Battery Ground Cable
Vehicle: 1997 Toyota RAV4 2-DOOR 2.0 L4 GAS
Audio Coded Anti-Theft System
Some models are equipped with an audio coded anti-theft system that will disable the radio when the battery cable is disconnected. The system can be identified by the "ANTI-THEFT SYSTEM" on the cassette lid. Obtain 3 digit code for input. Reset system after service as follows:
- Obtain 3 digit audio theft code.
- Depress 1 (PROG) while depressing righthand side of TUNE SEEK button,- - - will appear in tape operation display.
- To enter the first digit, depress 1 (PROG) button repeatedly until the number of times depressed equals the first digit (depress the 1 butto...
CLICK HERE TO GET FULL ACCESS TO 1997 Toyota RAV4 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1997 Toyota RAV4 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1997 Toyota RAV4 cars and light trucks from 1990+.
Power Brake Units -> Troubleshooting
Vehicle: 1997 Toyota RAV4 2.0 L4 GAS
Refer to "Hydraulic Brake Systems" ...
CLICK HERE TO GET FULL ACCESS TO 1997 Toyota RAV4 BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1997 Toyota RAV4 vehicle. |
Access the Complete guide! |