Auto Parts Search
2005 Chevrolet Uplander CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2005 Chevrolet Uplander AUTOMOBILES
Disc Brakes -> Delco Single Piston Sliding Caliper -> Tightening Specifications
Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Chevrolet Uplander AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Scheduled Maintenance -> Montana SV6, Relay, Terraza & Uplander -> Normal Service -> Severe Service
Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS
Normal Service
...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Chevrolet Uplander AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS
Front
- Raise and support vehicle, then remove tire and wheel assembly.
- Remove engine splash shield.
- Insert a suitable drift or punch through brake caliper and into brake rotor to prevent wheel hub and bearing from turning.
- Remove wheel drive shaft spindle nut.
- Remove stabilizer shaft link.
- Disconnect outer tie rod end from steering knuckle. Do not loosen tie rod end jam nut.
- Disconnect wheel speed sensor electrical connector, then reposition wiring harness away from ball joint.
- Disconnect lower ball joint from steering knuckle.
- Install wheel hub remover tool No. J 42129, or equival...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Chevrolet Uplander AUTOMOBILES
Alternator, Replace
Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS
- Disconnect battery ground cable.
- Remove wiper arms.
- Remove air inlet grill retainers, then air inlet grill.
- Lower washer fluid container into engine compartment.
- Disconnect wiper motor electrical connector.
- Remove wiper module assembly mounting bolts, then carefully guide passenger side of module out first from opening in front plenum.
- Pull module from driver side fender flange opening, then remove module from vehicle.
- Remove throttle body air inlet duct.
- Set parking brake and shift transmission into Neutral.
- Remove engine mount strut bolts, then swing engine mount struts aside.
- Insta...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 Chevrolet Uplander AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2005-07 Montana SV6, Relay, Terraza & 2005-08 Uplander
Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles or at Maintenance II as indicated on the DIC (Driver Information Center). In dusty areas change the cabin air filter more often.
- Open the glove compartment door.
- Remove the rear inside instrument panel compartment door.
- Open the cabin filter access door, Fig. .
- Remove the righthand cabin ...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Chevrolet Uplander AUTOMOBILES
General Motors Corp./Saturn Trucks -> Anti-Lock Brake System Warning Lamp ->
Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS
This lamp should light for approximately 6-8 seconds when the ignition is turned On as a bulb check. If the warn...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Chevrolet Uplander AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater core inlet hose clamp at module.
- Remove hose from module.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Drain cooling system into a suitable container.
- Reposition heater hose outlet clamp at heater core.
- Disconnect heater outlet hose from heater core.
- Reposition heater core outlet hose clamp at module.
- Remove hose from module.
- Remove hose from vehicle...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Chevrolet Uplander AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS
- Rotate drive belt tensioner counterclockwise t...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Chevrolet Uplander AUTOMOBILES
Component location diagrams for most 2005 Chevrolet Uplander cars and light trucks sold in the U.S. from 1990+.
I/P Component Locations Diagram for 2005 Chevrolet Uplander 3.5 V6 GAS Components on diagram: |
Seat Component Locations Diagram for 2005 Chevrolet Uplander 3.5 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Chevrolet Uplander AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Chevrolet Uplander cars and light trucks sold in the U.S.
2005 Chevrolet Uplander 3.5 V6 GAS Wiring Diagram Components on diagram: |
2005 Chevrolet Uplander 3.5 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Chevrolet Uplander AUTOMOBILES
OEM TSB listings for most 2005 Chevrolet Uplander cars and light trucks sold in the U.S. from 1985+.
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2005 Chevrolet Uplander 3.5 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Chevrolet Uplander AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Chevrolet Uplander cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Chevrolet Uplander cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Chevrolet Uplander cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Chevrolet Uplander cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Uplander SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2005 Chevrolet Uplander vehicle. |
Access the Complete guide! |