Auto Parts Search
2009 KIA Spectra CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT KIA REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 KIA Spectra AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2009 KIA Spectra EX 2.0 L4 GAS
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove wheel nuts and front wheels.
- Remove drain plug and drain transaxle fluid in suitable container.
- Remove driveshaft cotter pin, castle nut and washer from front hub.
- Disconnect tie rod end ball joint from steering knuckle using suitable tool.
- Remove bolts securing wheel speed sensor from steering knuckle.
- Disconnect strut upper mounting bolts.
- Tap on driveshaft front hub assembly using plastic hammer.
- Push front hub assembly outward and separate driveshaft from hub assembly.
- Insert suitable tool ...
CLICK HERE TO GET FULL ACCESS TO 2009 KIA Spectra DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 KIA Spectra AUTOMOBILES
Reset Procedures
Vehicle: 2009 KIA Spectra SX 2.0 L4 GAS
The Low Tire Pressure Warning lamp will illuminate for approximately three seconds as a bulb check when the ignition switch is placed in the On position. This system uses radio frequency pressure sensors which mon...
CLICK HERE TO GET FULL ACCESS TO 2009 KIA Spectra TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 KIA Spectra AUTOMOBILES
Alternator, Replace
Vehicle: 2009 KIA Spectra SX 2.0 L4 GAS
- Disconnect battery ground terminal first, then positive terminal.
- Disconnect alternator connector and remove cable from alternator B+ terminal.
- Remove power steering pump.
- Remove ...
CLICK HERE TO GET FULL ACCESS TO 2009 KIA Spectra STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 KIA Spectra AUTOMOBILES
Cabin Air Filter Service -> Kia -> 2004-09 Spectra & Spectra5 w/2.0L Engine
Vehicle: 2009 KIA Spectra SX 2.0 L4 GAS
Under normal operating conditions the cabin air filter should be replaced every 9,320 miles. In dusty areas change the cabin air filter more often.
- Open glove compartment to lower glove compartment down completely by re...
CLICK HERE TO GET FULL ACCESS TO 2009 KIA Spectra CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 KIA Spectra AUTOMOBILES
Kia -> Tire Pressure Monitoring System (System) Warning Indicator -> 2007-09 Spectra & Spectra5 -> Relearn -> Reset -> Tire Pressure Sensor Initiation -> TPMS Receiver
Vehicle: 2009 KIA Spectra EX 2.0 L4 GAS
Reset
The Low Tire Pressure Warning lamp will illuminate for approximately three seconds as a bulb check when the ignition switch is placed in the on position. This system uses radio frequency pressure sensors which monitor pressure in all 4 tires. When operating the vehicle at a speed above 20 mph the Low Tire Pressure Warning Lamp will illuminate when low tire pressure has been detected. Adjusting tires to correct pressure will turn lamp off.
Relearn
Tire Pressure Sensor Initiation
- Using Kia TPMS exciter tool, or equivalent, read the four tire pressure sensor IDs starti...
CLICK HERE TO GET FULL ACCESS TO 2009 KIA Spectra MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 KIA Spectra AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2009 KIA Spectra LX 2.0 L4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at thermostat housing.
- Remove hose from thermostat housing.
- Remove hose from vehicle.
- Reverse proc...
CLICK HERE TO GET FULL ACCESS TO 2009 KIA Spectra RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 KIA Spectra AUTOMOBILES
Serpentine Drive Belt, Replace -> Air Conditioning -> Alternator -> Power Steering
Vehicle: 2009 KIA Spectra EX 2.0 L4 GAS
Alternator
- Disconnect battery ground cable from battery.
- Loosen alternator upper locknut.
- Loosen lower mounting nut.
- Push alternator inward toward engine.
- Remove alternator drive belt.
- Clean and inspect belt surfaces of all pulleys.
- Reverse procedure to install, noting the following:
- Torque alternator mounting nut and bolt to 18 ft. lbs.
- Torque alternator adjustment lockbolt to 11 ft. lbs.
- Torque alternator brace mounting bolt to 17 ft. lbs.
Air ...
CLICK HERE TO GET FULL ACCESS TO 2009 KIA Spectra SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 KIA Spectra AUTOMOBILES
OEM TSB listings for most 2009 KIA Spectra cars and light trucks sold in the U.S. from 1985+.
Document: Enhanced Dealer Feedback and Digital Camera Requirements to Support Kia Quality Initiatives Vehicle: 2009 KIA Spectra SX 2.0 L4 GAS Auto Systems: |
Document: Load Carrying Capacity Label Requirements and Instructions to Comply With FMVSS 110 Vehicle: 2009 KIA Spectra SX 2.0 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 KIA Spectra TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 KIA Spectra AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 KIA Spectra cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 KIA Spectra cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 KIA Spectra cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 KIA Spectra cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 KIA Spectra SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 KIA Spectra vehicle. |
Access the Complete guide! |