Auto Parts Search
2008 Volvo XC90 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volvo REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2008 Volvo XC90 car and truck
repair procedures including Volvo engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Volvo XC90 automobile. Try the Automotix DIY solution today!
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2008 Volvo XC90 AUTOMOBILES
CV AXLE SHAFT, Replace -> Left Side -> Rear -> Right Side
Vehicle: 2008 Volvo XC90 3.2 3.2 L6 GAS
Left Side
- Raise and support vehicle on lift.
- On models with AWD, remove drain plug and drain transmission fluid.
- On all models, remove front wheel lug nuts.
- Remove bolt for wheel hub driveshaft.
- Counterhold using a suitable tool in brake disc vents.
- Tap end of drive shaft approximately 20-25mm into wheel hub.
- Remove nut for ball joint and control arm. If ball joint pinion moves, counterhold end of lug using suitable tool.
- Disconnect ball joint pinion from control arm using suitable tool.
- Install cap nut using suitable tool on ball joint pinion.
- Tighten nut against control arm, the...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2008 Volvo XC90 AUTOMOBILES
Component Locations
Vehicle: 2008 Volvo XC90 3.2 3.2 L6 GAS
Refer to F...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2008 Volvo XC90 AUTOMOBILES
Starter, Replace
Vehicle: 2008 Volvo XC90 V8 4.4 V8 GAS
- Disconnect both battery cables.
- Raise vehicle on suitable lift.
- Remove bolts securing suspension turrets.
- Remove bolts for upper engine mount on engine and remove upper cross stay mount.
- Open coolant reservoir cap.
- Remove bolts securing skid plate and lift forward to remove skid plate. There is a guide sleeve on upper mounting of skid plate. Skid plate must be lifted upward slightly in order to slide skid plate forward.
- Open drain plug on lower left bottom of radiator. Drain coolant in clean suitable container.
- Lower vehicle.
- Disconnect ECM connector.
- Remove air cleaner housing by disco...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2008 Volvo XC90 AUTOMOBILES
Cabin Air Filter Service -> Volvo -> 1999-2006 S80, 2001-09 S60, 2001-07 V70, XC70 & 2003-09 XC90
Vehicle: 2008 Volvo XC90 V8 Sport 4.4 V8 GAS
The cabin air filter should be replaced every 15,000 miles. The filter should be replaced more often if air flow is less than normal.
- Remove the sound proofing panel from under the passenger side of the instrument panel.
- Remove the cabin air filter cover retaining screws, then the cover, Fig. .
- Press down on the cabin air filte...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2008 Volvo XC90 AUTOMOBILES
Volvo -> Anti-Lock Brake System (ABS)/Dynamic Stability & Traction Control (DSTC)/Stability Traction Control (STC) Warning Lamp ->
Vehicle: 2008 Volvo XC90 3.2 3.2 L6 GAS
The warning lamp is used to warn of an system fault. The lamp input monitors the condition of the system. The lamp will be lit during engine start-up, but should go out when the self-diagnostic sy...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2008 Volvo XC90 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2008 Volvo XC90 3.2 3.2 L6 GAS
Lower
- Drain coolant into a suitable container.
- Reposition clamp at radiator and remove hose.
- Reposition clamp at coolant pipe and remove hose.
- Remove hose from vehicle.
- Reverse procedure to...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2008 Volvo XC90 AUTOMOBILES
Serpentine Drive Belt, Replace -> Power Steering Bleed
Vehicle: 2008 Volvo XC90 3.2 3.2 L6 GAS
- Unsnap and remove battery box cover.
- Disconnect battery ground cable, then positive cable.
- Remove battery, surround, and mounting bolts .
- Unsnap and remove engine cover.
- Raise and support vehicle.
- Remove engine splash shield and fasteners.
- Loosen clamps and remove air outlet pipe.
- Disconnect electrical connector from mass airflow (MAF) sensor.
- Disconnect air inlet pipe from air cleaner.
- Remove battery tray.
- Remove power steering hose brackets and mounting nuts from A/C compressor.
- Remove A/C compressor control unit from A/C compressor.
- Rotate tensioner, using a suitable tool ...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2008 Volvo XC90 AUTOMOBILES
Component location diagrams for most 2008 Volvo XC90 cars and light trucks sold in the U.S. from 1990+.
 Instrument Panel Diagram for 2008 Volvo XC90 3.2 3.2 L6 GASComponents on diagram: |
 Engine Compartment Diagram for 2008 Volvo XC90 V8 4.4 V8 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2008 Volvo XC90 AUTOMOBILES
OEM drawn wiring diagrams for most 2008 Volvo XC90 cars and light trucks sold in the U.S.
 2008 Volvo XC90 V8 4.4 V8 GAS Wiring DiagramComponents on diagram: |
 2008 Volvo XC90 V8 Sport 4.4 V8 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2008 Volvo XC90 AUTOMOBILES
OEM TSB listings for most 2008 Volvo XC90 cars and light trucks sold in the U.S. from 1985+.
|
Document: HIGH OIL CONSUMPTION SI6 NON-TURBO Vehicle: 2008 Volvo XC90 V8 4.4 V8 GAS Auto Systems: |
|
Document: DIFFERENTIAL ELECTRONIC MODULE (DEM), SOFTWARE (SW) - REVISED Vehicle: 2008 Volvo XC90 V8 4.4 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2008 Volvo XC90 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2008 Volvo XC90 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2008 Volvo XC90 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2008 Volvo XC90 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2008 Volvo XC90 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo XC90 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2008 Volvo XC90 vehicle.
|
| Access the Complete guide! |
