Auto Parts Search
2007 Volvo XC70 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volvo REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Volvo XC70 AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2007 Volvo XC70 2.5 L5 GAS
- Raise and support vehicle on lift.
- Remove front member from body, exhaust pipe and Three-Way Catalytic Converter.
- Remove brake pipe from mountings in member. If the same driveshaft is to be reinstalled. Mark the driveshaft CV joint in relation to the bevel gear flange.
- Support front section of exhaust pipe so as not to put strain on exhaust manifold.
- Remove rear exhaust system assembly.
- Remove bolts from joint using suitable tool to hold driveline while removing bolts.
- Leave one bolt in place by a few threads for safety.
- On models with vibration dampner, hold driveline with suitab...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Volvo XC70 AUTOMOBILES
Relearn Procedures
Vehicle: 2007 Volvo XC70 2.5 L5 GAS
There are two ways to relearn a tire pressure sensor ID. Drive the vehicle faster than 25 mph for longer than 10 minutes. The warning for low tire pressure remains in the DIM (Driver Informati...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Volvo XC70 AUTOMOBILES
Alternator, Replace
Vehicle: 2007 Volvo XC70 2.5 L5 GAS
- Disconnect battery ground cable.
- Detach pipe from control module box.
- Rotate or lift belt tensioner arm counterclockwise, using a suitable tool to relieve tension from drive belt.
- Remove drive belt.
- Loosen clamps and remove power steering pump hoses. Drain fluid in a clean suitable container. Avoid skin contact with power steering fluid.
- Remove cold air inlet hose to control module.
- Loosen bolt on power steering line lock bracket.
- Loosen pipe nipple on pump.
- Remove bolts from power steering pump pulley holes and lift pump up to remove.
- Loosen hose clamps, disconnect coolant hose fr...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Volvo XC70 AUTOMOBILES
Cabin Air Filter Service -> Volvo -> 1999-2006 S80, 2001-09 S60, 2001-07 V70, XC70 & 2003-09 XC90
Vehicle: 2007 Volvo XC70 2.5 L5 GAS
The cabin air filter should be replaced every 15,000 miles. The filter should be replaced more often if air flow is less than normal.
- Remove the sound proofing panel from under the passenger side of the instrument panel.
- Remove the cabin air filter cover retaining screws, then the cover, Fig. .
- Press down on the cabin air filte...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Volvo XC70 AUTOMOBILES
Volvo -> Check Engine Lamp ->
Vehicle: 2007 Volvo XC70 2.5 L5 GAS
This lamp should be illuminated when the ignition switch is placed in the On position. After the engine has been started, the lamp should go out. If it remains lit, a problem has b...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Volvo XC70 AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2007 Volvo XC70 2.5 L5 GAS
Inlet
- Drain coolant into a suitable container.
- Reposition clamp on heat exchanger feed pipe and remove hose.
- Reposition clamp on cylinder head nipple and remove hose.
- Remove hose from vehicle.
- Reverse procedur...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Volvo XC70 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Volvo XC70 2.5 L5 GAS
- Disconnect negative battery cable.
- Remove cover over engine control module box and move it to one side.
- Remove engine control module by carefully pulling it up and out using a suitable tool. Do not touch terminal pins on engine contro...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Volvo XC70 AUTOMOBILES
Component location diagrams for most 2007 Volvo XC70 cars and light trucks sold in the U.S. from 1990+.
Taillight Components Diagram for 2007 Volvo XC70 2.5 L5 GAS Components on diagram: |
Headlamp Components Diagram for 2007 Volvo XC70 2.5 L5 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Volvo XC70 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Volvo XC70 cars and light trucks sold in the U.S.
2007 Volvo XC70 2.5 L5 GAS Wiring Diagram Components on diagram: |
2007 Volvo XC70 2.5 L5 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Volvo XC70 AUTOMOBILES
OEM TSB listings for most 2007 Volvo XC70 cars and light trucks sold in the U.S. from 1985+.
Document: DIFFERENTIAL ELECTRONIC MODULE (DEM), SOFTWARE (SW) - REVISED Vehicle: 2007 Volvo XC70 2.5 L5 GAS Auto Systems: |
Document: TRANSMISSION CONTROL MODULE (TCM), SOFTWARE (SW) - REVISED Vehicle: 2007 Volvo XC70 2.5 L5 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Volvo XC70 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Volvo XC70 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Volvo XC70 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Volvo XC70 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Volvo XC70 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo XC70 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Volvo XC70 vehicle. |
Access the Complete guide! |