Auto Parts Search
2007 Volvo V70 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volvo REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2007 Volvo V70 car and truck
repair procedures including Volvo engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Volvo V70 automobile. Try the Automotix DIY solution today!
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Volvo V70 AUTOMOBILES
CV AXLE SHAFT, Replace -> Left Side -> Right Side
Vehicle: 2007 Volvo V70 2.4 2.4 L5 GAS
Left Side
- Raise and support vehicle on lift.
- Remove hub cap.
- Remove front wheel lug nuts.
- Remove bolt for wheel hub driveshaft.
- Tap end of drive shaft approximately 15-20mm into wheel hub.
- Remove anti-roll bar strut from spring strut.
- Counterhold ball joint pinion so that ball joint boot cannot turn.
- Detach brake hose from its mounting lug in spring strut.
- Detach ABS line from its mounting lug in wheel arch.
- Slacken off nut for ball joint for control arm. Before removing the nuts from the ball joints, clean the exposed threads of rust. Lubricate using rust solvent before removing t...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Volvo V70 AUTOMOBILES
Relearn Procedures
Vehicle: 2007 Volvo V70 2.4 2.4 L5 GAS
There are two ways to relearn a tire pressure sensor ID. Drive the vehicle faster than 25 mph for longer than 10 minutes. The warning for low tire pressure remains in the DIM (Driver Informati...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Volvo V70 AUTOMOBILES
Starter, Replace
Vehicle: 2007 Volvo V70 R 2.5 L5 GAS
- Disconnect battery ground cable.
- Remove intake manifold between front cover plate and air cleaner housing.
- On models equipped with turbo, loosen hose clamps between charge air cooler and electronic throttle module, disconnect electrical connector and remove charge air cooler hose.
- On all model...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Volvo V70 AUTOMOBILES
Cabin Air Filter Service -> Volvo -> 1999-2006 S80, 2001-09 S60, 2001-07 V70, XC70 & 2003-09 XC90
Vehicle: 2007 Volvo V70 2.5T 2.5 L5 GAS
The cabin air filter should be replaced every 15,000 miles. The filter should be replaced more often if air flow is less than normal.
- Remove the sound proofing panel from under the passenger side of the instrument panel.
- Remove the cabin air filter cover retaining screws, then the cover, Fig. .
- Press down on the cabin air filte...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Volvo V70 AUTOMOBILES
Volvo -> Tire Pressure Monitoring System (TPMS) Warning Indicator -> 2005-07 V70 -> Relearn -> Reset
Vehicle: 2007 Volvo V70 2.4 2.4 L5 GAS
Reset
If the system detects low tire pressure, a warning message will be displayed on the instrument panel and the tire pressure warning lamp will be illuminated. Inflating tire to recommended pressure and driving the vehicle at a speed of 20 mph or faster for several minutes will clear the tire message.
Volvo recommends that all wheels installed on the vehicle, with the exception of the temporary spare tire, be equipped with Volvo tire pressure monitor system sensors. Wheels without tire pressure monitor system sensors will cause ...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Volvo V70 AUTOMOBILES
Radiator, Replace
Vehicle: 2007 Volvo V70 2.5T 2.5 L5 GAS
- Remove electric cooling fan.
- On turbocharged models, disconnect charge air pipe from charge air cooler (CAC) on lefthand side. If necessary, use a hot air gun to make removal easier
- On all models, remove screws for radiator unit on front cover plate.
- Remove two upper screws holding radiator unit together.
- Remove expansion tank cap.
- Block upper radiator hose with lock grip pliers.
- Raise and support vehicle.
- Remove air baffles.
- Remove lower oil cooler hose from radiator unit. Collect oil in a suitable container.
- Remove screw for mounting for cable duct for engine wiring at front edge of...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Volvo V70 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Volvo V70 2.4 2.4 L5 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Volvo V70 AUTOMOBILES
Component location diagrams for most 2007 Volvo V70 cars and light trucks sold in the U.S. from 1990+.
 Rear Lights Diagram for 2007 Volvo V70 2.4 2.4 L5 GASComponents on diagram: |
 Body Components Diagram for 2007 Volvo V70 2.5T 2.5 L5 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Volvo V70 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Volvo V70 cars and light trucks sold in the U.S.
 2007 Volvo V70 R 2.5 L5 GAS Wiring DiagramComponents on diagram: |
 2007 Volvo V70 R 2.5 L5 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Volvo V70 AUTOMOBILES
OEM TSB listings for most 2007 Volvo V70 cars and light trucks sold in the U.S. from 1985+.
|
Document: HIGH OIL CONSUMPTION SI6 NON-TURBO Vehicle: 2007 Volvo V70 2.4 2.4 L5 GAS Auto Systems: |
|
Document: TRANSMISSION CONTROL MODULE (TCM), SOFTWARE (SW) - REVISED Vehicle: 2007 Volvo V70 2.4 2.4 L5 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Volvo V70 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Volvo V70 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Volvo V70 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Volvo V70 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Volvo V70 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V70 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2007 Volvo V70 vehicle.
|
| Access the Complete guide! |
