Auto Parts Search
2004 Buick Rendezvous CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Buick REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
Component Replacement & Adjustment -> Aztek & Rendezvous -> Blower Motor, Replace
Vehicle: 2004 Buick Rendezvous 3.6 V6 GAS
- Remove instrument panel insulator push-in and dash mat retainers.
- Disconnect panel courtesy lamp and remove instrument panel insulator.
- Disconnect blower motor electrical connector.
- Remove mounting screws and blower motor, Fig. . ...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
Disc Brakes -> Delco Single Piston Sliding Caliper -> Troubleshooting -> Brake Rattle -> Brake Roughness Or Chatter; Pedal Pumping -> Caliper Brake Fluid Leak -> Excessive Pedal Effort -> Excessive Pedal Travel -> Heavy Brake Drag -> No Braking Effect When Brake Pedal Is Depressed -> Pull, Uneven Or Grabbing Brakes -> Rear Brakes Locking On Application
Vehicle: 2004 Buick Rendezvous 3.4 V6 GAS
Excessive Pedal Travel
- Worn brake linings.
- Disc pads knock back after cornering or rough road travel.
- Piston and linings not properly seated or positioned.
- Insufficient fluid in system.
- Loose wheel bearing adjustment.
- Damaged or worn caliper piston seal.
- Improper booster pushrod adjustment.
- Pads out of flat more than .005 inch.
- Rear brake automatic adjusters inoperative.
- Improperly ground rear brake shoes.
Brake Roughness Or Chatter; Pedal Pumping
- Excessive lateral runout of rotor.
- Rotor excessively out of parallel.
Excessive Pedal Effort
- Frozen or seized pistons.
- Brake fluid, oil or grease on ...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> Gasoline Engines Except Equinox, Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Uplander & Vue (2004-06) & 2004-06 Envoy, Rainier & TrailBlazer -> Returnless Fuel System
Vehicle: 2004 Buick Rendezvous 3.4 V6 GAS
Returnless Fuel System
On models equipped with fuel injected engines, relieve fuel system pressure as outlined under "Fuel System Pressure Relief."
On models equipped with metal collar quick disconnect connectors, GM tool No. J37088-A, or equivalent, will be required to disconnect the connector. Pri...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2004 Buick Rendezvous 3.4 V6 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Intermittent & Poor Connections -> Intermittents -> Poor Connections -> Scan Tool Data Definitions
Vehicle: 2004 Buick Rendezvous 3.6 V6 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Scan Tool Data Definitions
Refer to Fig. for scan tool data definitions.
Clearing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector), and follow manufacturer's instructions.
Intermittent & Poor Connections
Intermittents
Most intermittents are caused by faulty electrical connections or wiring. Inspect for the following:
- Wiring broken inside insulation.
- Poor connection between male and female terminal ...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
Alternator, Replace
Vehicle: 2004 Buick Rendezvous 3.6 V6 GAS
- Disconnect battery ground cable.
- Remove torque struts and rotate engine to access alternator.
- Remove alternator B+ terminal nut and battery cable from alternator.
- Disconnect alternator electrical connector.
- Remove drive belt from alternator.
- Remove id...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2004-07 Rendezvous
Vehicle: 2004 Buick Rendezvous Ultra 3.6 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Pull tab located on outer access panel upward and outward, F...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
General Motors Corp./Saturn Trucks -> Reduce Engine Power Indicator Lamp ->
Vehicle: 2004 Buick Rendezvous 3.6 V6 GAS
The Reduce Engine Power indicator lamp should light for a approximately 3 seconds when the ignition is turned On as a bulb check. If the warning lamp turns On during vehicle operation, a vehicl...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
Radiator, Replace
Vehicle: 2004 Buick Rendezvous 3.6 V6 GAS
- Recover A/C refrigerant.
- Drain cooling system into a suitable container.
- Remove cooling fans with cooling fan shroud.
- Remove air cleaner and duct assembly.
- Remove cooling fan harness electrical connector.
- Remove righthand side diagonal brace.
- Loosen engine mount strut nuts.
- Remove engine mount strut bracket brace bolts from upper radiator support and rotate struts and brackets rearward.
- Remove upper radiator hose.
- Remove radiator upper mount bolts and mounts.
- Remove cooling fan shroud bolts.
- Reposition coolant overflow hose clamp at radiator using suitable hose clamp pliers.
- Disconnect an...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2004 Buick Rendezvous AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2004 Buick Rendezvous Ultra 3.6 V6 GAS
- Raise vehicle and suitably support.
- Remove righthand engine splash shield.
- Rotate drive belt tensioner clockwise to release drive ...
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2004 Buick Rendezvous AUTOMOBILES
Component location diagrams for most 2004 Buick Rendezvous cars and light trucks sold in the U.S. from 1990+.
Left Rear Of Engine Diagram for 2004 Buick Rendezvous 3.4 V6 GAS Components on diagram: |
Power Seat Subsystem Diagram for 2004 Buick Rendezvous 3.6 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2004 Buick Rendezvous AUTOMOBILES
OEM drawn wiring diagrams for most 2004 Buick Rendezvous cars and light trucks sold in the U.S.
2004 Buick Rendezvous 3.4 V6 GAS Wiring Diagram Components on diagram: |
2004 Buick Rendezvous 3.4 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2004 Buick Rendezvous AUTOMOBILES
OEM TSB listings for most 2004 Buick Rendezvous cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2004 Buick Rendezvous 3.4 V6 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2004 Buick Rendezvous 3.4 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2004 Buick Rendezvous AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2004 Buick Rendezvous cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2004 Buick Rendezvous cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2004 Buick Rendezvous cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2004 Buick Rendezvous cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2004 Buick Rendezvous SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2004 Buick Rendezvous vehicle. |
Access the Complete guide! |