Auto Parts Search
BRAKE SERVICE PROCEDURES FOR 2004 Acura TSX AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2004 Acura TSX cars and light trucks from 1990+.
Acura -> Power Brake Units -> Adjustments -> Brake Pedal Height -> Pushrod Clearance
Vehicle: 2004 Acura TSX 2.4 L4 GAS
Brake Pedal Height
- Disconnect brake switch connector.
- Loosen brake switch locknut and back switch off until no longer touches brake pedal.
- Turn up floor mat and measure pedal height from lefthand center of pedal pad
- Loosen locknut and turn pushrod to specified height, Fig. .
- Torque locknut to 11 ft. lbs.
- On 3.2CL, 3.2TL and 3.2RL models, turn in brake light switch until plunger is fully depressed. Back switch off 1/4 turn to .01 inch clearance. Tighten locknut.
- On RL, RSX, TL, TSX and MDX models, turn in brake light switch until plunger is fully depressed. Turn switch 45º clockwise to lock...
CLICK HERE TO GET FULL ACCESS TO 2004 Acura TSX BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Acura TSX AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2004 Acura TSX cars and light trucks from 1990+.
Acura -> Hydraulic Brake Systems -> Component Replacement -> Master Cylinder
Vehicle: 2004 Acura TSX 2.4 L4 GAS
Master Cylinder
- On MDX models, remove intake air duct and throttle cable holder.
- On RL models, proceed as follows:
- Remove engine compartment covers.
- Remove mounting bolts and position underhood fuse/relay box aside.
- Remove mounting bolts, nuts and strut brace.
- On RSX models, remove air cleaner.
- On TL models, proceed as follows:
- Remove engine compartment covers.
- Remove mounting bolts and position underhood fuse/relay box aside.
- Remove mounting bolt and engine wire harness clamp from strut brace.
- Remove Accelerator Pedal Position (APP) sensor mounting bolt from strut brace.
- Remove mount...
CLICK HERE TO GET FULL ACCESS TO 2004 Acura TSX BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Acura TSX AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2004 Acura TSX cars and light trucks from 1990+.
Acura -> Power Brake Units -> Diagnosis & Testing -> Check Valve Test -> Function Test -> Leak Test
Vehicle: 2004 Acura TSX 2.4 L4 GAS
Function Test
- With engine stopped, deplete vacuum reservoir by depressing brake pedal several times.
- Depress pedal hard and hold for 15 seconds. If pedal sinks, either of the following may exist:
- Master cylinder is bypassing internally.
- Master cylinder, lines, modulator proportioning valve or caliper are leaking.
- With brake pedal depressed, start engine. Not the following:
- If pedal sinks slightly, vacuum booster is operating normally.
- If pedal height does not vary, booster or check valve is faulty.
- With engine running, depress brake pedal lightly to keep automatic transaxle from cre...
CLICK HERE TO GET FULL ACCESS TO 2004 Acura TSX BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Acura TSX AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2004 Acura TSX cars and light trucks from 1990+.
Acura -> Disc Brakes -> Rotor, Replace -> Front -> Rear
Vehicle: 2004 Acura TSX 2.4 L4 GAS
Front
- Raise and support front of vehicle, then remove tire and wheel assemblies.
- Remove pin bolt and pivot caliper up away from rotor.
- Remove stud clips and slide rotor off hub.
- Reverse procedure to install.
Rear
- Raise and support rear of vehicle, then rem...
CLICK HERE TO GET FULL ACCESS TO 2004 Acura TSX BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Acura TSX AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2004 Acura TSX cars and light trucks from 1990+.
Acura -> Hydraulic Brake Systems -> Adjustments
Vehicle: 2004 Acura TSX 2.4 L4 GAS
Refer t...
CLICK HERE TO GET FULL ACCESS TO 2004 Acura TSX BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Acura TSX AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2004 Acura TSX cars and light trucks from 1990+.
Acura -> Disc Brakes -> Precautions -> Radio Coded Theft Protection System
Vehicle: 2004 Acura TSX 2.4 L4 GAS
Radio Coded Theft Protection System
Anti-theft radios have a coded theft protection circuit. The security code number must be obtained before disconnecting battery, removing radio fuse or ...
CLICK HERE TO GET FULL ACCESS TO 2004 Acura TSX BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2004 Acura TSX vehicle. |
Access the Complete guide! |