Auto Parts Search
2002 Buick Rendezvous CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Buick REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2002 Buick Rendezvous AUTOMOBILES
Component Replacement & Adjustment -> Light Duty Trucks & Vans -> Compressor, Replace -> 1.6L Engine -> 2.0L & 2.5L Engines -> 2.2L Engine -> 4.2L Engine -> 4.3L Engine -> 4.8L, 5.3L, 6.0L & 8.1L Engines -> 6.6L Diesel Engine -> Astro & Safari -> Aztek -> Bravada, S & T Series -> C & K Series -> G Series -> Montana, Silhouette & Venture -> Rendezvous -> Tracker -> Vue
Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS
Astro & Safari
- Remove air cleaner.
- Remove upper half of fan shroud.
- Recover refrigerant as outlined under .
- Disconnect electrical connector from A/C clutch.
- Remove drive belt.
- Remove engine cover.
- Remove oil filler tube.
- Disconnect electrical connector from A/C compressor high pressure cutoff switch.
- Remove compressor hose assembly bolt from compressor.
- Remove compressor hose assembly seal washers.
- Remove bolts securing compressor to mounting bracket, then the compressor, Fig. .
- Reverse procedure to install...
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Buick Rendezvous AUTOMOBILES
Hydraulic Brake Systems -> Adjustments -> Height Sensing Proportioning Valve
Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS
Height Sensing Proportioning Valve
The height sensing proportioning valve must be adjusted whenever the valve and/or linkage is disassembled or removed for service. In addition, adjustment should be inspected if excessive front wheel lock-up is experienced with a lower than desired brake application rate when vehicle is at or near maximum GVWR.
- Raise and support vehicle, leave wheels on and allow axle to hang freely.
- Remove lever retaining nut and disconnect lever from valve shaft,. Fig. .
- Rotate valve shaft to permit installation of correct adjustment gauge,. Fig. , ensure D shaped hol...
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Buick Rendezvous AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Scheduled Maintenance -> Aztek & Rendezvous -> Normal Service -> Severe Service
Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS
Normal Service
Service as...
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Buick Rendezvous AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS
- Raise and support vehicle.
- Scribe propeller shaft reference mark on transfer case flange.
- Remove propeller shaft to transfer case flange attaching bolts.
- Scribe propeller shaft reference mark on torque tube flange.
- Remove propeller shaft to torque tube flange attaching bolts.
- Push propeller shaft ...
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Buick Rendezvous AUTOMOBILES
Starter, Replace
Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS
- Raise and support vehicle.
- Remove air baffle bolts, then the air baffle.
- Remove starter motor BAT terminal nut and electrical leads.
- Remove starter motor S terminal nut and electrical lead.
- Remove torque converter cover.
- Remove starter motor mounting bolts, th...
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Buick Rendezvous AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1998-2005 Montana, Silhouette, Trans Sport, Venture & 2002-03 Rendezvous
Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Open the instrument panel compartment door.
- Remove the door located at the rear of the instrument panel compartment.
- Open the A/C and heater module access door, Fig. .
- Remove the first cabin air filter through the A/C and heater module access...
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Buick Rendezvous AUTOMOBILES
General Motors Corp./Saturn Trucks -> Air Cleaner Restriction Indicator ->
Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS
An air cleaner restriction indicator, Fig. , is located in the intake duct between the MAF sensor and the air cleaner assembly.
If the window shows green, no service is required at this time. However, if...
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Buick Rendezvous AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS
Inlet
- Drain cooling system into a suitable container.
- Remove wiper motor module assembly.
- Disconnect vacuum hose from brake booster and reposition.
- Remove air cleaner cover and intake tube.
- Disconnect throttle and cruise control cables. Disconnect throttle and cruise control cables from TBI mounting bracket to prevent bending cable housings.
- Remove transmission fluid filler tube.
- Reposition heater core inlet hose clamp at inlet heater pipe.
- Remove hose from inlet heater pipe.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Remove hose from...
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Buick Rendezvous AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS
- Release belt pressure by rotating te...
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Buick Rendezvous AUTOMOBILES
Component location diagrams for most 2002 Buick Rendezvous cars and light trucks sold in the U.S. from 1990+.
Behind IP Compartment Diagram for 2002 Buick Rendezvous 3.4 V6 GAS Components on diagram: |
HVAC Air Plenum Diagram for 2002 Buick Rendezvous 3.4 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Buick Rendezvous AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Buick Rendezvous cars and light trucks sold in the U.S.
2002 Buick Rendezvous 3.4 V6 GAS Wiring Diagram Components on diagram: |
2002 Buick Rendezvous 3.4 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Buick Rendezvous AUTOMOBILES
OEM TSB listings for most 2002 Buick Rendezvous cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2002 Buick Rendezvous 3.4 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Buick Rendezvous AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Buick Rendezvous cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Buick Rendezvous cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Buick Rendezvous cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Buick Rendezvous cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Buick Rendezvous SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2002 Buick Rendezvous vehicle. |
Access the Complete guide! |