Auto Parts Search
1997 GEO Tracker CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GEO REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 1997 GEO Tracker AUTOMOBILES
Component Replacement & Adjustment -> Light Duty Trucks & Vans -> Compressor, Replace -> Astro & Safari -> Bravada & S/T Series -> C & K Series -> G & P Series -> Silhouette, Trans Sport, 1996 Lumina APV & 1997 Venture -> Tracker -> V6 Engines
Vehicle: 1997 GEO Tracker 1.6 L4 GAS
Astro & Safari
V6 Engines
- Recover refrigerant as outlined under .
- Remove the engine cover, then disconnect electrical connectors from compressor and clutch.
- Loosen idle pulley and disconnect compressor drive belt.
- Remove compressor manifold attaching bolt and manifold from rear of compressor, then cap all connections.
- Remove carburetor vacuum break to provide clearance, if necessary.
- Remove bolts securing compressor to mounting bracket, then compressor, Fig. .
- Reverse procedure to install, using new O-rings when install...
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker A/C & HEATER SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1997 GEO Tracker AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> Gasoline Engines Except Equinox, Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Uplander & Vue (2004-06) & 2004-06 Envoy, Rainier & TrailBlazer -> Returnless Fuel System
Vehicle: 1997 GEO Tracker 1.6 L4 GAS
Returnless Fuel System
On models equipped with fuel injected engines, relieve fuel system pressure as outlined under "Fuel System Pressure Relief."
On models equipped with metal collar quick disconnect connectors, GM tool No. J37088-A, or equivalent, will be required to disconnect the connector. Pri...
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1997 GEO Tracker AUTOMOBILES
CV AXLE SHAFT, Replace -> Left -> Right
Vehicle: 1997 GEO Tracker 1.6 L4 GAS
Left
- Raise and support vehicle.
- Remove skid plate bolts and skid plate, if equipped.
- Remove front tire and wheel assembly.
- Remove the six hub flange bolts and flange.
- Remove drive axle shaft snap ring.
- Remove drive axle shaft spindle washer from drive axle shaft.
- Use a hydraulic jack in order to support the front control arm. To prevent personal injury and/or component damage, use the proper tools to support the lower control arm when removing the coil spring. The coil spring is under extreme pressure and can become a projectile should the spring separate from the lower control ...
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1997 GEO Tracker AUTOMOBILES
Alternator, Replace
Vehicle: 1997 GEO Tracker 1.6 L4 GAS
- Disconnect battery ground cable.
- Remove air cleaner hose.
- Slide EVAP canister from mounting bracket at inner fender.
- Loosen lower alternator pivot mounting bolt.
- Remove adjusting mounting bolt and drive belt.
- Disconnect a...
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1997 GEO Tracker AUTOMOBILES
General Motors Corp./Saturn Trucks -> All Wheel Drive (AWD) System Warning Lamp ->
Vehicle: 1997 GEO Tracker 1.6 L4 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned On as a bulb check. If the war...
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1997 GEO Tracker AUTOMOBILES
Radiator, Replace
Vehicle: 1997 GEO Tracker 1.6 L4 GAS
- Remove radiator pressure cap.
- Raise and support vehicle.
- Drain engine coolant into suitable container then remove and plug transmission fluid cooler hoses from radiator.
- Remove lower shroud bolts and lower radiator outlet hose.
- Lower vehicle.
- On models equipped with air conditioning, remove mounting bolts and position air co...
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 1997 GEO Tracker AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 1997 GEO Tracker 1.6 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1997 GEO Tracker AUTOMOBILES
Component location diagrams for most 1997 GEO Tracker cars and light trucks sold in the U.S. from 1990+.
Floor Harness Diagram for 1997 GEO Tracker 1.6 L4 GAS Components on diagram: |
Front Door (LH Shown, RH Similar) Diagram for 1997 GEO Tracker 1.6 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1997 GEO Tracker AUTOMOBILES
OEM drawn wiring diagrams for most 1997 GEO Tracker cars and light trucks sold in the U.S.
1997 GEO Tracker 1.6 L4 GAS Wiring Diagram Components on diagram: |
1997 GEO Tracker 1.6 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1997 GEO Tracker AUTOMOBILES
OEM TSB listings for most 1997 GEO Tracker cars and light trucks sold in the U.S. from 1985+.
Document: RECREATIONAL (DINGY) TOWING - REVISED Vehicle: 1997 GEO Tracker 1.6 L4 GAS Auto Systems: |
Document: INFORMATION ON USE OF DIAGNOSTIC WORKSHEET - REVISED Vehicle: 1997 GEO Tracker 1.6 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1997 GEO Tracker AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1997 GEO Tracker cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1997 GEO Tracker cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1997 GEO Tracker cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1997 GEO Tracker cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1997 GEO Tracker SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1997 GEO Tracker vehicle. |
Access the Complete guide! |