Auto Parts Search
1990 Volvo 760 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volvo REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
A/C & HEATER SERVICE PROCEDURES FOR 1990 Volvo 760 AUTOMOBILES
A/C & Cooling System Maintenance -> Volvo -> 1990-98
Vehicle: 1990 Volvo 760 2.3 L4 GAS
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1990 Volvo 760 AUTOMOBILES
VOLVO, POWER BRAKE UNITS -> SYSTEM SERVICE -> CHECK VALVE, REPLACE -> POWER BRAKE BOOSTER, REPLACE
Vehicle: 1990 Volvo 760 GLE 2.8 V6 GAS
POWER BRAKE BOOSTER, REPLACE
- Remove master cylinder, then disconnect vacuum hose from power brake unit.
- Disconnect link arm from brake pedal, then remove bracket with clutch pedal stop.
- Remove nuts attaching power brake unit to dash panel.
- Pull power brake unit forward, then disconnect fork from link arm and remove brake unit.
CHECK VALVE, R...
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 1990 Volvo 760 AUTOMOBILES
Volvo -> Fuel Filter Scheduled Maintenance -> 1986-95 -> Normal Service -> Severe Service
Vehicle: 1990 Volvo 760 GLE 2.8 V6 GAS
Normal Service
Replace every 60,000 m...
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 1990 Volvo 760 AUTOMOBILES
DRIVESHAFT U-JOINT, Replace
Vehicle: 1990 Volvo 760 GLE 2.8 V6 GAS
- Raise and support vehicle.
- Remove u-joint bolts.
- Pry shaft backwards slightly and tilt it down forward...
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 1990 Volvo 760 AUTOMOBILES
Alternator, Replace
Vehicle: 1990 Volvo 760 GLE 2.8 V6 GAS
- Disconnect battery ground cable.
- Rotate or lift belt tensioner arm counterclockwise, using a suitable tool to relieve tension from drive belt.
- Remove drive belt.
- Loosen clamps and remove power steering pump hoses. Drain fluid in a clean suitable container. Avoid skin contact with power steering fluid.
- Remove cold air inlet hose to control module.
- Loosen bolt on power steering line lock bracket.
- Loosen pipe nipple on pump.
- Remove bolts from power steering pump pulley holes and lift pump up to remove.
- Loosen hose clamps, disconnect coolant hose from radiator, and place to one side. Dr...
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 1990 Volvo 760 AUTOMOBILES
Volvo -> Check Engine Lamp ->
Vehicle: 1990 Volvo 760 2.3 L4 GAS
This lamp should be illuminated when the ignition switch is placed in the On position. After the engine has been started, the lamp should go out. If it remains lit, a problem has b...
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 1990 Volvo 760 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 1990 Volvo 760 2.3 L4 GAS
Lower
- Drain coolant into a suitable container.
- Reposition lower hose clamp at radiator and remove hose.
- Reposition lower hose clamp at water pump and remove hose.
- Remove hose from vehicle.
- Reverse procedure to i...
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 RADIATOR & HOSE REPLACEMENT PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 1990 Volvo 760 AUTOMOBILES
Component location diagrams for most 1990 Volvo 760 cars and light trucks sold in the U.S. from 1990+.
Power Seats Components Diagram for 1990 Volvo 760 GLE 2.8 V6 GAS Components on diagram: |
Supplemental Restraint System Components Diagram for 1990 Volvo 760 2.3 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 1990 Volvo 760 AUTOMOBILES
OEM drawn wiring diagrams for most 1990 Volvo 760 cars and light trucks sold in the U.S.
1990 Volvo 760 GLE 2.8 V6 GAS Wiring Diagram Components on diagram: |
1990 Volvo 760 2.3 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 1990 Volvo 760 AUTOMOBILES
OEM TSB listings for most 1990 Volvo 760 cars and light trucks sold in the U.S. from 1985+.
Document: STUCK CDS IN AUDIO UNIT Vehicle: 1990 Volvo 760 GLE 2.8 V6 GAS Auto Systems: |
Document: ROAD SIDE ASSISTANCE ON CALL - REVISED Vehicle: 1990 Volvo 760 GLE 2.8 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 1990 Volvo 760 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 1990 Volvo 760 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 1990 Volvo 760 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 1990 Volvo 760 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 1990 Volvo 760 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 1990 Volvo 760 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 1990 Volvo 760 vehicle. |
Access the Complete guide! |