Auto Parts Search
2005 Chevrolet Suburban 2500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
Hydraulic Brake Systems -> Adjustments -> Height Sensing Proportioning Valve
Vehicle: 2005 Chevrolet Suburban 2500 LS 6.0 V8 GAS
Height Sensing Proportioning Valve
The height sensing proportioning valve must be adjusted whenever the valve and/or linkage is disassembled or removed for service. In addition, adjustment should be inspected if excessive front wheel lock-up is experienced with a lower than desired brake application rate when vehicle is at or near maximum GVWR.
- Raise and support vehicle, leave wheels on and allow axle to hang freely.
- Remove lever retaining nut and disconnect lever from valve shaft, Fig. .
- Rotate valve shaft to permit installation of correct adjustment gauge, Fig. , ensure D shaped hol...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> Gasoline Engines Except Equinox, Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Uplander & Vue (2004-06) & 2004-06 Envoy, Rainier & TrailBlazer -> Returnless Fuel System
Vehicle: 2005 Chevrolet Suburban 2500 LS 6.0 V8 GAS
Returnless Fuel System
On models equipped with fuel injected engines, relieve fuel system pressure as outlined under "Fuel System Pressure Relief."
On models equipped with metal collar quick disconnect connectors, GM tool No. J37088-A, or equivalent, will be required to disconnect the connector. Pri...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2005 Chevrolet Suburban 2500 LT 6.0 V8 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Aids -> Diagnostic Check -> Diagnostic Tests -> Intermittent & Poor Connections -> Intermittents -> Poor Connections -> Test Procedures
Vehicle: 2005 Chevrolet Suburban 2500 LS 6.0 V8 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Tests
Test Procedures
Refer to Figs. through for diagnostic test procedures.
Diagnostic Check
- Check for aftermarket devices which could affect the operation of the TPMS to verify that none are installed.
- Check the easily accessible or visible system components for obvious damage or conditions which could cause the symptom.
- Ensure that the scan tool selected front and rear tire pressure parameters are correct compared to the tire...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
Starter, Replace
Vehicle: 2005 Chevrolet Suburban 2500 LT 6.0 V8 GAS
- Disconnect battery ground cable.
- Remove mounting bolts and engine shield, if required.
- Remove mounting bolts and oil pan skid plate, if required.
- Remove righthand transmission cover bolt.
- Remove front axle mounting bracket nut, then position front axle mounting bracket bolt until tip is flush with support bushing. Do not remove bolt.
- Remove starter motor mounting bolts and slide starter forward until it clears transmission.
- Disconnect oil level sensor electrical connector.
- Remove starter...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2005 Chevrolet Suburban 2500 LT 6.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
General Motors Corp./Saturn Trucks -> Traction Control System (TCS)/Electronic Stability Control (ESC) Warning Lamp ->
Vehicle: 2005 Chevrolet Suburban 2500 LS 8.1 V8 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned On as a bulb check. If t...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2005 Chevrolet Suburban 2500 LT 6.0 V8 GAS
Lower
- Drain cooling system into a suitable container.
- Remove air cleaner outlet duct clamps at throttle body and mass air flow (MAF)/intake air temperature (IAT) sensor.
- Remove radiator inlet hose clip from outlet hose.
- Remove air cleaner outlet duct.
- Reposition hose clamp from water pump housing.
- Remove radiator outlet hose from water pump housing.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator and from vehicle.
- Reverse procedure to install.
Upper
- Drain cooling system into a suitable ...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Chevrolet Suburban 2500 LS 8.1 V8 GAS
- Rotate tensioner counterclockwise, using suitab...
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
Component location diagrams for most 2005 Chevrolet Suburban 2500 cars and light trucks sold in the U.S. from 1990+.
LR of the Engine Compartment Components-Cruise Control Diagram for 2005 Chevrolet Suburban 2500 LS 6.0 V8 GAS Components on diagram: |
LF Corner of the Vehicle-Wiper/Washer Components Diagram for 2005 Chevrolet Suburban 2500 LS 8.1 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Chevrolet Suburban 2500 cars and light trucks sold in the U.S.
2005 Chevrolet Suburban 2500 LS 6.0 V8 GAS Wiring Diagram Components on diagram: |
2005 Chevrolet Suburban 2500 LT 8.1 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
OEM TSB listings for most 2005 Chevrolet Suburban 2500 cars and light trucks sold in the U.S. from 1985+.
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2005 Chevrolet Suburban 2500 LS 6.0 V8 GAS Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2005 Chevrolet Suburban 2500 LS 6.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Chevrolet Suburban 2500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Chevrolet Suburban 2500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Chevrolet Suburban 2500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Chevrolet Suburban 2500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Chevrolet Suburban 2500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Chevrolet Suburban 2500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2005 Chevrolet Suburban 2500 vehicle. |
Access the Complete guide! |