JAYCO LEGACY PROBLEMS | SAFETY RECALLS & DEFECTS

JAYCO LEGACY PROBLEMS | SAFETY RECALLS & DEFECTS

Access the National Highway Traffic Safety database of JAYCO LEGACY recalls and defective parts found on JAYCO LEGACY automobiles. The National Highway Traffic Safety administration is authorized to order the JAYCO LEGACY manufacturers to recall and repair vehicles or parts of motor vehicle equipment when its investigation indicates that they contain serious safety defects in their design, structure, body, or performance.

Select Your Vehicle Year (Change Vehicle)

2009	2004	2003	2002
2001

Most Recent Recalls For JAYCO LEGACY

Vehicle	Component	Manufacterer
2003-2004 JAYCO LEGACY EQUIPMENT:RECREATIONAL VEHICLE Recall
2003-2004 JAYCO LEGACY	EQUIPMENT:RECREATIONAL VEHICLE Units affected: 387	JAYCO, INC. Report Date: 2010-12-17
Summary: JAYCO IS RECALLING CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
2004 JAYCO LEGACY EQUIPMENT Recall
2004 JAYCO LEGACY	EQUIPMENT Units affected: 207	JAYCO, INC. Report Date: 2010-09-21
Summary: JAYCO IS RECALLING CERTAIN MODEL YEAR 2004 LEGACY AND MODEL YEAR 2005 DESIGNER FIFTH WHEEL TRAILERS EQUIPPED WITH DIMPLEX ELECTRAFLAME, SYMPHONY, OR OPTIFLAME BRANDED ELECTRIC FIREPLACES, STOVES, AND FIREPLACE INSERTS. THE PLUG IN REMOTE CONTROL RECEIVER FOR THE FIREPLACE CAN OVERHEAT.
2002-2004 JAYCO LEGACY EQUIPMENT Recall
2002-2004 JAYCO LEGACY	EQUIPMENT Units affected: 273	JAYCO, INC. Report Date: 2009-07-23
Summary: JAYCO IS RECALLING 273 MODEL YEAR 2002-2004 LEGACY FIFTH WHEEL MOTORHOMES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.
2009 JAYCO LEGACY ELECTRICAL SYSTEM:WIRING Recall
2009 JAYCO LEGACY	ELECTRICAL SYSTEM:WIRING Units affected: 46	JAYCO, INC. Report Date: 2009-03-31
Summary: JAYCO IS RECALLING 46 MY 2009 LEGACY SERIES 37RLSA AND 36RLMS FIFTH WHEEL TRAILERS. THERE MAY BE A MISSING GROUND WIRE BETWEEN THE TRAILER FRAME AND THE 12-VOLT BUS BAR.
2009 JAYCO LEGACY EQUIPMENT:OTHER:LABELS Recall
2009 JAYCO LEGACY	EQUIPMENT:OTHER:LABELS Units affected: 28	JAYCO, INC. Report Date: 2008-09-11
Summary: JAYCO IS RECALLING 28 MY 2009 LEGACY FIFTH WHEEL TRAVEL TRAILERS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THERE IS A TYPOGRAPHICAL ERROR INCORRECTLY STATING THE TIRE LOAD RANGE AND THE INFLATION PRESSURE ON THE FEDERAL IDENTIFICATION LABEL FOR THE REAR AXLE.
2001-2003 JAYCO LEGACY WHEELS Recall
2001-2003 JAYCO LEGACY	WHEELS Units affected: 742	JAYCO, INC. Report Date: 2004-07-21
Summary: ON CERTAIN TRAVEL TRAILERS, DUE TO VARIOUS FACTORS, INCLUDING EXCESSIVE PAINT COATING ON THE BRAKE HUB, THE ALUMINUM WHEELS COULD EXHIBIT LESSENED CLAMPING PRESSURE BETWEEN THE ALUMINUM WHEEL AND THE AXLE HUB ASSEMBLY.
2002-2004 JAYCO LEGACY EQUIPMENT:RECREATIONAL VEHICLE Recall
2002-2004 JAYCO LEGACY	EQUIPMENT:RECREATIONAL VEHICLE Units affected: 6442	JAYCO, INC. Report Date: 2003-10-09
Summary: ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.