IC CE PROBLEMS | SAFETY RECALLS & DEFECTS

IC CE PROBLEMS | SAFETY RECALLS & DEFECTS

Access the National Highway Traffic Safety database of IC CE recalls and defective parts found on IC CE automobiles. The National Highway Traffic Safety administration is authorized to order the IC CE manufacturers to recall and repair vehicles or parts of motor vehicle equipment when its investigation indicates that they contain serious safety defects in their design, structure, body, or performance.

Select Your Vehicle Year (Change Vehicle)

2011	2010	2009	2008
2007	2006	2005	2004
2003	2002	2001

Most Recent Recalls For IC CE

Vehicle	Component	Manufacterer
2006-2008 IC CE VEHICLE SPEED CONTROL Recall
2006-2008 IC CE	VEHICLE SPEED CONTROL Units affected: 4131	NAVISTAR, INC Report Date: 2010-06-15
Summary: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2008 IC BE, RE, AND CE SCHOOL BUSES MANUFACTURED FROM DECEMBER 4, 2001 THROUGH DECEMBER 14, 2009 EQUIPPED WITH INTERNATIONAL VT365 ENGINES HAVING ENGINE CALIBRATION PAN2PVR0, PAN2PVR1, OR PAN2PWR. THE ENGINE NORMALLY RESPONDS TO A FAILED OPEN ACCELERATOR POSITION SENSOR CIRCUIT FAULT BY RETURNING THE ENGINE TO LOW IDLE SPEED OF 800 RPM AND DISABLING THE DRIVER'S ABILITY TO INCREASE THE ENGINE SPEED. HOWEVER IF THE OPEN CIRCUIT CORRECTS ITSELF WITHIN 30 SECONDS OF INITIATION, ENGINE SPEED COULD SUDDENLY INCREASE TO A HIGH IDLE SPEED OF 1200 RPM.
2005-2008 IC CE VEHICLE SPEED CONTROL Recall
2005-2008 IC CE	VEHICLE SPEED CONTROL Units affected: 2085	NAVISTAR, INC Report Date: 2010-06-15
Summary: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 INTERNATIONAL TRUCKS AND IC COMMERCIAL BUSES MANUFACTURED FROM DECEMBER 4, 2001 THROUGH DECEMBER 14, 2009 EQUIPPED WITH INTERNATIONAL VT365 ENGINES HAVING ENGINE CALIBRATION PAN2PVR0, PAN2PVR1, OR PAN2PWR. THE ENGINE NORMALLY RESPONDS TO A FAILED OPEN ACCELERATOR POSITION SENSOR CIRCUIT FAULT BY RETURNING THE ENGINE TO LOW IDLE SPEED OF 800 RPM AND DISABLING THE DRIVER'S ABILITY TO INCREASE THE ENGINE SPEED. HOWEVER IF THE OPEN CIRCUIT CORRECTS ITSELF WITHIN 30 SECONDS OF INITIATION, ENGINE SPEED COULD SUDDENLY INCREASE TO A HIGH IDLE SPEED OF 1200 RPM.
2009-2011 IC CE EQUIPMENT ADAPTIVE Recall
2009-2011 IC CE	EQUIPMENT ADAPTIVE Units affected: 1492	NAVISTAR, INC Report Date: 2010-06-14
Summary: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 IC CE, FE, RE, AND BE MODEL SCHOOL BUSES MANUFACTURED FROM DECEMBER 10, 2007 THROUGH JANUARY 12, 2010 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.
2009-2011 IC CE EQUIPMENT ADAPTIVE Recall
2009-2011 IC CE	EQUIPMENT ADAPTIVE Units affected: 20	NAVISTAR, INC Report Date: 2010-06-14
Summary: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 IC CE, FE, RE, AND BE MODEL NON SCHOOL BUSES MANUFACTURED FROM DECEMBER 10, 2007 THROUGH JANUARY 12, 2010 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.
2010 IC CE EQUIPMENT ADAPTIVE Recall
2010 IC CE	EQUIPMENT ADAPTIVE Units affected: 6	NAVISTAR, INC Report Date: 2010-06-14
Summary: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2010 IC BE AND CE SCHOOL BUSES MANUFACTURED FROM APRIL 22 THROUGH MAY 14, 2009, AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.
2005-2011 IC CE SERVICE BRAKES, HYDRAULIC Recall
2005-2011 IC CE	SERVICE BRAKES, HYDRAULIC Units affected: 5016	NAVISTAR, INC Report Date: 2010-03-16
Summary: NAVISTAR HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 AND 2011 IC CE, BE, AND FE SCHOOL BUSES MANUFACTURED FROM NOVEMBER 19, 2003 THROUGH FEBRUARY 9, 2010. THE PARKING BRAKE MAY RELEASE IF THE BRAKE SYSTEM ELECTRONIC CONTROL UNIT SOFTWARE MISINTERPRETS INPUT SIGNALS GENERATED FROM CYCLING THE IGNITION SWITCH MORE THAN ONCE AT A SPECIFIC FREQUENCY.
2010-2011 IC CE SERVICE BRAKES, HYDRAULIC Recall
2010-2011 IC CE	SERVICE BRAKES, HYDRAULIC Units affected: 87	NAVISTAR, INC Report Date: 2010-03-16
Summary: NAVISTAR HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 AND 2011 IC CE, HC, AND BE COMMERCIAL BUSES AND INTERNATIONAL 1300, 3200, 3300, 4100, 4200, 4300, 4400, AND MXT TRUCKS MANUFACTURED FROM NOVEMBER 19, 2003 THROUGH FEBRUARY 9, 2010. THE PARKING BRAKE MAY RELEASE IF THE BRAKE SYSTEM ELECTRONIC CONTROL UNIT (ECU) SOFTWARE MISINTERPRETS INPUT SIGNALS GENERATED FROM CYCLING THE IGNITION SWITCH MORE THAN ONCE AT A SPECIFIC FREQUENCY.
2009-2010 IC CE EQUIPMENT:ELECTRICAL:AIR CONDITIONER Recall
2009-2010 IC CE	EQUIPMENT:ELECTRICAL:AIR CONDITIONER Units affected: 630	NAVISTAR, INC Report Date: 2009-07-28
Summary: NAVISTAR IS RECALLING 630 MODEL YEAR 2009 AND 2010 IC SCHOOL AND COMMERCIAL BUSES MANUFACTURED BETWEEN FEBRUARY 1, 2008 AND JULY 6, 2009, EQUIPPED WITH TRANS/AIR AIR CONDITIONING SYSTEMS. EACH TRANS/AIR SYSTEM COMES WITH AN ELECTRICAL KIT AND EC PC BOARD WHICH IF IMPROPERLY INSTALLED COULD OVERHEAT.
2009-2010 IC CE OTHER:SCHOOL BUS STOP ARM ASSEMBLY Recall
2009-2010 IC CE	OTHER:SCHOOL BUS STOP ARM ASSEMBLY Units affected: 3449	NAVISTAR, INC Report Date: 2009-07-28
Summary: NAVISTAR IS RECALLING 3,449 IC SCHOOL BUSES MANUFACTURED BETWEEN MARCH 1, 2008 AND FEBRUARY 1, 2009, EQUIPPED WITH SPECIALTY MANUFACTURING, INC. (SMI) 000290 LED LIGHT KITS. A CHANGE TO THE WIRE USED IN THE LED LIGHT KITS MAY REDUCE THE EFFECTIVE LIFE OF THE LIGHTS USED ON THE STOP ARMS. THE LIGHTS MAY STOP FUNCTIONING WITHOUT WARNING.
2009-2010 IC CE ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN Recall
2009-2010 IC CE	ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN Units affected: 7521	NAVISTAR, INC Report Date: 2009-03-30
Summary: NAVISTAR IS RECALL 7,521 MY 2009 INTERNATIONAL MODEL TRUCKS AND MY 2009 AND 2010 IC SCHOOL AND TRANSIT BUSES MANUFACTURED FROM APRIL 1, 2008 TO DECEMBER 12, 2008, EQUIPPED WITH A HORTON 2-SPEED FAN DRIVE, IDENTIFIED BY FEATURE CODE 12THT. THE FASTENERS THAT CONNECT THE MAGNET BRACKETS TO THE AIR CHAMBER HOUSING OF THE 2-SPEED ENGINE FAN COULD FAIL RESULTING IN THE MAGNET BRACKET BEING THROWN FROM THE FAN DRIVE AND THE VEHICLE AT HIGH SPEED.