2006 DAMON CHALLENGER RECALLS/DEFECTS & PROBLEMS

2006 DAMON CHALLENGER RECALLS/DEFECTS & PROBLEMS

Access the National Highway Traffic Safety database of 2006 DAMON CHALLENGER recalls and defects found on 2006 DAMON CHALLENGER automobiles. The National Highway Traffic Safety administration is authorized to order the 2006 DAMON CHALLENGER manufacturers to recall and repair vehicles or parts of motor vehicle equipment when its investigation indicates that they contain serious safety defects in their structure, or performance.  Look up customer problems!

Select Component (Change Vehicle)

- ENGINE AND ENGINE COOLING
- EQUIPMENT:RECREATIONAL VEHICLE
- EXTERIOR LIGHTING
- SERVICE BRAKES, HYDRAULIC
- STEERING

Most Recent Recalls For 2006 DAMON CHALLENGER

Vehicle	Component	Manufacterer
2001-2009 DAMON CHALLENGER SERVICE BRAKES, HYDRAULIC Recall
2001-2009 DAMON CHALLENGER	SERVICE BRAKES, HYDRAULIC Units affected: 2415	DAMON CORPORATION Report Date: 2009-06-16
Summary: DAMON IS RECALLING 2,415 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG.
2004-2006 DAMON CHALLENGER EQUIPMENT:RECREATIONAL VEHICLE Recall
2004-2006 DAMON CHALLENGER	EQUIPMENT:RECREATIONAL VEHICLE Units affected: 4677	DAMON CORPORATION Report Date: 2008-10-09
Summary: DAMON IS RECALLING 4,677 MY 2004-2006 CHALLENGER, DAYBREAK, INTRUDER, MY 2004-2005 ESCAPER, ULTRASPORT, AND MY 2005 ASTORIA AND ASTORIA WALDORF MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
2006-2007 DAMON CHALLENGER EXTERIOR LIGHTING Recall
2006-2007 DAMON CHALLENGER	EXTERIOR LIGHTING Units affected: 2618	DAMON CORPORATION Report Date: 2007-01-30
Summary: CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE MOTOR HOMES WERE BUILT WITHOUT THE RED REAR REFLEX REFLECTORS AND SOME MOTOR HOMES WERE BUILT WITHOUT THE SIDE REAR RED REFLEX REFLECTORS.
2004-2007 DAMON CHALLENGER ENGINE AND ENGINE COOLING Recall
2004-2007 DAMON CHALLENGER	ENGINE AND ENGINE COOLING Units affected: 1517	DAMON CORPORATION Report Date: 2006-11-28
Summary: ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
2006 DAMON CHALLENGER EQUIPMENT:RECREATIONAL VEHICLE Recall
2006 DAMON CHALLENGER	EQUIPMENT:RECREATIONAL VEHICLE Units affected: 1592	DAMON CORPORATION Report Date: 2006-09-12
Summary: ON CERTAIN CLASS A MOTOR HOMES, SOME HYDRAULIC LINES FOR THE LEVELING JACK SYSTEM MAY BE IMPROPERLY SECURED OR ROUTED TOO CLOSE TO A DRIVE TRAIN HEAT SOURCE.
2005-2007 DAMON CHALLENGER STEERING Recall
2005-2007 DAMON CHALLENGER	STEERING Units affected: 116	DAMON CORPORATION Report Date: 2006-06-30
Summary: CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.