Auto Parts Search
2009 Subaru Outback CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Subaru REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2009 Subaru Outback car and truck
repair procedures including Subaru engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Subaru Outback automobile. Try the Automotix DIY solution today!
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Subaru Outback AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2009 Subaru Outback 3.0 R Limited 3.0 H6 GAS
Wrap metal parts with a cloth or rubber material. Rubber boot may be damaged due to interference with adjacent metal parts during removal.
- Disconnect battery ground cable.
- Place vehicle in neutral.
- Release parking brake.
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove center exhaust pipes bolts and nuts.
- Remove rear exhaust pipe and muffler.
- Remove heat shield cover.
- Place reference mark on front driveline and rear differential flange. Paint is recommended for match marks. Never damage rear driveline shaft flange yoke or companion flange
- Remove...
CLICK HERE TO GET FULL ACCESS TO 2009 Subaru Outback DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Subaru Outback AUTOMOBILES
Wiring Diagrams -> Wire Color Code Identification
Vehicle: 2009 Subaru Outback XT Limited 2.5 H4 GAS
Refer to Fig. for wirin...
[[table data]]CLICK HERE TO GET FULL ACCESS TO 2009 Subaru Outback TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Subaru Outback AUTOMOBILES
Alternator, Replace
Vehicle: 2009 Subaru Outback 2.5I 2.5 H4 GAS
- Disconnect ground cable from battery.
- Remove front side belts.
- Disconnect connector and terminal from alternator.
- Remove ...
CLICK HERE TO GET FULL ACCESS TO 2009 Subaru Outback STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 Subaru Outback AUTOMOBILES
Cabin Air Filter Service -> Subaru -> 2005-06 Baja & 2005-09 Legacy & Outback
Vehicle: 2009 Subaru Outback XT Limited 2.5 H4 GAS
The cabin air filter should be replaced every 12 months or 9,300 miles.
- Remove the instrument panel side cover.
- Remove the glove compartment retaining clips and damper, then the glove compartment, Fig. .
- Remove the glove compartment upper storage bin.
- Through the glove compar...
CLICK HERE TO GET FULL ACCESS TO 2009 Subaru Outback CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Subaru Outback AUTOMOBILES
Subaru -> Check Engine Lamp -> 1995-2009 Legacy & Outback
Vehicle: 2009 Subaru Outback 3.0 R Limited 3.0 H6 GAS
The Check Engine lamp will be illuminated when the ignition switch is placed in the On position. When the engine is started, the lamp should go out. If it remains lit after engine start-up, the self-diagnostic system has detected a problem and stored a diagnostic trouble code. After diagnosis and repair are complete, the self-diagnostic system memory can be cleared using the scan tool. Follow sc...
CLICK HERE TO GET FULL ACCESS TO 2009 Subaru Outback MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Subaru Outback AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2009 Subaru Outback 3.0 R Limited 3.0 H6 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater hose inlet clamp at water outlet using hose clamp pliers.
- Remove heater inlet hose from water outlet.
- Reposition heater core inlet hose clamp at heater core using hose clamp pliers.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Drain cooling system into a suitable container.
- Reposition heater hose outlet clamp at water inlet using hose clamp pliers.
- Disco...
CLICK HERE TO GET FULL ACCESS TO 2009 Subaru Outback RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Subaru Outback AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Subaru Outback 2.5I 2.5 H4 GAS
- Remove drive belt cover. Wipe off any oil or water on belt and pulley.
- Loosen lockbolt on slider bolt.
- Loosen slider bolt.
- ...
CLICK HERE TO GET FULL ACCESS TO 2009 Subaru Outback SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Subaru Outback AUTOMOBILES
OEM TSB listings for most 2009 Subaru Outback cars and light trucks sold in the U.S. from 1985+.
|
Document: RES Immobilizer Antenna Ring Clip Vehicle: 2009 Subaru Outback 2.5I 2.5 H4 GAS |
|
Document: Service Manual Corrections Vehicle: 2009 Subaru Outback 2.5I 2.5 H4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Subaru Outback TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Subaru Outback AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Subaru Outback cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Subaru Outback cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Subaru Outback cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Subaru Outback cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Subaru Outback SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2009 Subaru Outback vehicle.
|
| Access the Complete guide! |
