Auto Parts Search
2009 Pontiac G3 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Pontiac REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Pontiac G3 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2009 Pontiac G3 1.6 L4 GAS
- Remove hub nut.
- Raise and support vehicle.
- Remove ball joint to steering knuckle nut.
- Break ball joint loose from steering knuckle.
- Push axle...
CLICK HERE TO GET FULL ACCESS TO 2009 Pontiac G3 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Pontiac G3 AUTOMOBILES
Relearn Procedures
Vehicle: 2009 Pontiac G3 1.6 L4 GAS
- Place the ignition switch in the On position with engine Off.
- Using a suitably programmed scan tool, place TPMS control unit in the Learn Mode. A double horn chirp will sound to indicate the Learn Mode has started.
- If GM tool No. J-46079 or equivalent, is not available, proceed as follows:
- Starting with the left front tire, rapidly increase or decrease tire pressure by at least 1.2 psi until a horn chirp is sounded.
- When the horn chirp has sounded, the sensor information is learned.
- Repeat the procedure on the right front, right rear and left rear tires.
- If GM tool No. J-46079 or e...
CLICK HERE TO GET FULL ACCESS TO 2009 Pontiac G3 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Pontiac G3 AUTOMOBILES
Alternator, Replace
Vehicle: 2009 Pontiac G3 1.6 L4 GAS
- Disconnect battery ground cable from battery.
- Raise and support vehicle.
- Remove accessory drive belt.
- Remove battery harness connector nut to disconnect battery positive connector.
- Disconnect alternator harness c...
CLICK HERE TO GET FULL ACCESS TO 2009 Pontiac G3 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 Pontiac G3 AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2004-09 Aveo & 2009 G3
Vehicle: 2009 Pontiac G3 1.6 L4 GAS
On 2004-08 models, under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
On 2009 models, under normal operating conditions the cabin air filter should be replaced every 12 months or 15,000 miles or at Maintenance II as indicated on the DIC (Driver Information Center). In dusty areas change the cabin air filter more often.
- Open the glove compartment door.
- Grasp the upper and lower portions of the glove compartment and pull the compartment out from the housing, Fig. .
- Through the glov...
CLICK HERE TO GET FULL ACCESS TO 2009 Pontiac G3 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Pontiac G3 AUTOMOBILES
General Motors Corp./Saturn Cars -> Active Handling System Warning Lamp ->
Vehicle: 2009 Pontiac G3 1.6 L4 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned on as a bulb check. The lamp will also come on as the system is...
CLICK HERE TO GET FULL ACCESS TO 2009 Pontiac G3 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Pontiac G3 AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2009 Pontiac G3 1.6 L4 GAS
Inlet
- Drain coolant into a suitable container.
- Loosen hose clamp connecting hose to heater core inlet tube.
- Loosen hose clamp connecting hose to water pump bypass tube.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO 2009 Pontiac G3 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Pontiac G3 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Pontiac G3 1.6 L4 GAS
To remove power steering pump belt, do remove accessory belt in advance.
- Rotate tensioner star-nut counterclockwis...
CLICK HERE TO GET FULL ACCESS TO 2009 Pontiac G3 SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Pontiac G3 AUTOMOBILES
OEM TSB listings for most 2009 Pontiac G3 cars and light trucks sold in the U.S. from 1985+.
Document: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE Vehicle: 2009 Pontiac G3 1.6 L4 GAS Auto Systems: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2009 Pontiac G3 1.6 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Pontiac G3 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Pontiac G3 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Pontiac G3 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Pontiac G3 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Pontiac G3 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Pontiac G3 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Pontiac G3 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Pontiac G3 vehicle. |
Access the Complete guide! |