Auto Parts Search
2009 GMC Sierra 1500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GMC REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 GMC Sierra 1500 AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2009 GMC Sierra 1500 SLT 6.0 V8 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2009 GMC Sierra 1500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 GMC Sierra 1500 AUTOMOBILES
Wiring Diagrams -> Wire Color Code Identification
Vehicle: 2009 GMC Sierra 1500 SLE 6.0 V8 GAS
Refer to Figs. through for w...
[[table data]]CLICK HERE TO GET FULL ACCESS TO 2009 GMC Sierra 1500 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 GMC Sierra 1500 AUTOMOBILES
Starter, Replace
Vehicle: 2009 GMC Sierra 1500 SLE 5.3 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove transmission cover bolt.
- Remove starter mounting bolts.
- Disconnect engine wiring harness electrical connector from oil level sensor. Avoid cable and wiring damage. DO NOT suspend starter by cables or wires attached to solenoid terminals. Use a rope or mechanics wire to suspend starter.
- Slide starter forward until starter clears transmission and properly support starter.
- Lower vehicle half way.
- Remove right front wheel and tire.
- Remove right front wheelhouse liner.
- Remove engine wiring ha...
CLICK HERE TO GET FULL ACCESS TO 2009 GMC Sierra 1500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 GMC Sierra 1500 AUTOMOBILES
General Motors Corp./Saturn Trucks -> Check Engine Oil Level ->
Vehicle: 2009 GMC Sierra 1500 SLT 5.3 V8 FLEX
This system is used to indicate a low engine oil level condition. The lamp should light during engine starting. If oil level is sufficient, the lamp should go off when engine is operating. If oil level is low the...
CLICK HERE TO GET FULL ACCESS TO 2009 GMC Sierra 1500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 GMC Sierra 1500 AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2009 GMC Sierra 1500 SL 4.8 V8 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition hose clamp at heater core and remove hose.
- Reposition hose clamp at heater inlet pipe and remove hose.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO 2009 GMC Sierra 1500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 GMC Sierra 1500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 GMC Sierra 1500 SLT 5.3 V8 FLEX
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2009 GMC Sierra 1500 SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 GMC Sierra 1500 AUTOMOBILES
OEM TSB listings for most 2009 GMC Sierra 1500 cars and light trucks sold in the U.S. from 1985+.
Document: EI07082-Power Steering Fluid Leaking from Power Steering Gear/Rack Assembly Vehicle: 2009 GMC Sierra 1500 WT 4.3 V6 GAS Symptoms: |
Document: Second Order Prop Shaft Vibration Or Launch Shudder Vehicle: 2009 GMC Sierra 1500 WT 4.3 V6 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2009 GMC Sierra 1500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 GMC Sierra 1500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 GMC Sierra 1500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 GMC Sierra 1500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 GMC Sierra 1500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 GMC Sierra 1500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 GMC Sierra 1500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 GMC Sierra 1500 vehicle. |
Access the Complete guide! |