Auto Parts Search
2008 Chevrolet Colorado CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2008 Chevrolet Colorado AUTOMOBILES
Disc Brakes -> Delco Dual Piston Sliding Caliper -> Precautions -> Brake Disc Service -> Brake Lines & Linings -> Brake Roughness -> General
Vehicle: 2008 Chevrolet Colorado LT 2.9 L4 GAS
Brake Lines & Linings
Remove one of the front wheels and inspect the brake disc, caliper and linings.
Do not allow any oil or grease on the linings. It is recommended that linings be replaced in sets when worn or damaged.
If the caliper is cracked or fluid leakage through the casting is evident, it must be replaced as a unit.
Brake Roughness
The most common cause of brake chatter on disc brakes is a variation in thickness of the disc. If roughness or vibration is encountered during highway operation or if pedal pumping is experienced at low speeds, the disc may have excessive thickness v...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2008 Chevrolet Colorado AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2008 Chevrolet Colorado LT 3.7 L5 GAS
- Raise and support vehicle.
- Remove wheel and tire assembly.
- Remove wheel drive shaft nut and washer. Do not reuse wheel drive shaft nut, replace with new.
- Remove steering knuckle assembly.
- Release wheel drive shaft by placing a brass drift against tripod housing. Firmly strike brass drift with a hammer to release drive shaft.
- Remove front wheel drive shaft from vehicle.
- Reverse procedure to install, noting the following:
- A snap or po...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2008 Chevrolet Colorado AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic System Check -> Diagnostic Tests -> DTC C0750 Left Front Low Tire Pressure Sensor, C0755 Right Front Low Tire Pressure Sensor, C0760 Left Rear Low Tire Pressure Sensor Or C0765 Right Rear Low Tire Pressure Sensor -> DTC C0775 Low Tire Pressure System Sensors Not Learned -> Intermittent & Poor Connections -> Intermittents -> Low Tire Pressure Indicator Fault -> Poor Connections
Vehicle: 2008 Chevrolet Colorado LT 2.9 L4 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Tests
Low tire pressure in one or more tires is indicated by a continuously illuminated TPMS indicator after the bulb check is completed. The DIC will display a check tire pressure type message, if equipped. It is not necessary to perform the Relearn procedure for a low tire condition.
When a TPMS DTC is set, the TPMS indicator will flash for one minute after the bulb check is completed and then will remain illuminated. The DI...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2008 Chevrolet Colorado AUTOMOBILES
Alternator, Replace
Vehicle: 2008 Chevrolet Colorado LS 3.7 L5 GAS
- Disconnect battery ground cable.
- Remove drive belt.
- Raise and support vehicle only high enough to access air conditioning compressor through wheelhouse.
- Remove left front wheel.
- Remove push-pins and left wheelhouse liner.
- Disengage air conditioning compressor electrical connector from bracket.
- Remove air conditioning compressor mounting bolts. Evacuation of air conditioning refrigerant will not be required. Upper mounting bolt will remain with air conditioning compressor.
- Lower vehicle.
- Disconnect engine wiring harness electrical connector from alternator.
- Reposition alternator out...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2008 Chevrolet Colorado AUTOMOBILES
General Motors Corp./Saturn Trucks -> Check Engine Oil Level ->
Vehicle: 2008 Chevrolet Colorado LT 2.9 L4 GAS
This system is used to indicate a low engine oil level condition. The lamp should light during engine starting. If oil level is sufficient, the lamp should go off when engine is operating. If oil level is low the...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2008 Chevrolet Colorado AUTOMOBILES
Radiator, Replace
Vehicle: 2008 Chevrolet Colorado LT 3.7 L5 GAS
- Drain radiator coolant into suitable container.
- Disconnect upper coolant reservoir hose.
- Remove mounting bolts and upper fan shroud.
- On models equipped with automatic transmission,disconnect and plug transmission fluid cool...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2008 Chevrolet Colorado AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2008 Chevrolet Colorado LS 2.9 L4 GAS
- Rotate tensioner clockwise, using suitable 3/8 inch breaker bar.
- Slide drive belt from water pump pul...
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2008 Chevrolet Colorado AUTOMOBILES
Component location diagrams for most 2008 Chevrolet Colorado cars and light trucks sold in the U.S. from 1990+.
Door Components Diagram for 2008 Chevrolet Colorado WT 3.7 L5 GAS Components on diagram: |
Instrument Panel Diagram for 2008 Chevrolet Colorado LS 2.9 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2008 Chevrolet Colorado AUTOMOBILES
OEM drawn wiring diagrams for most 2008 Chevrolet Colorado cars and light trucks sold in the U.S.
2008 Chevrolet Colorado LT 2.9 L4 GAS Wiring Diagram Components on diagram: |
2008 Chevrolet Colorado WT 2.9 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2008 Chevrolet Colorado AUTOMOBILES
OEM TSB listings for most 2008 Chevrolet Colorado cars and light trucks sold in the U.S. from 1985+.
Document: Engine Rattle Noise after R And R of the Crankshaft Balancer -Inspect Bolt Torque Vehicle: 2008 Chevrolet Colorado LT 3.7 L5 GAS Symptoms: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2008 Chevrolet Colorado LT 3.7 L5 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2008 Chevrolet Colorado AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2008 Chevrolet Colorado cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2008 Chevrolet Colorado cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2008 Chevrolet Colorado cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2008 Chevrolet Colorado cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2008 Chevrolet Colorado SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2008 Chevrolet Colorado vehicle. |
Access the Complete guide! |