Auto Parts Search
2007 Volkswagen Beetle CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volkswagen REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Volkswagen Beetle AUTOMOBILES
CV AXLE SHAFT, Replace -> With CV Joint and Triple Roller Joint -> With Triple Roller Joint
Vehicle: 2007 Volkswagen Beetle 2.5 2.5 L5 GAS
With CV Joint and Triple Roller Joint
Wheel bearing must not be burdened while 12 point nut is loose.
If wheel bearing is burdened by weight of vehicle, wheel bearing will be pre-damaged. This will diminish wheel bearing service life.
If it should be necessary to move a vehicle whose drive axle has been removed, before doing so install an outer joint in place of drive axle and tighten it to 11 ft. lbs., or else wheel bearing will be damaged.
- Lift vehicle enough that front axle is no longer burdened.
- Remove 12 point nut.
- Raise and support vehicle.
- Remove wheel.
- Remove sound insula...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Volkswagen Beetle AUTOMOBILES
Component Replacement -> Installation -> Removal -> TPMS Sensor
Vehicle: 2007 Volkswagen Beetle 2.5 2.5 L5 GAS
TPMS Sensor
Removal
When TPMS sensor battery is discharge, the entire sensor must be replaced. Use only original valve caps and valve insert.
- Loosen the wheel lug nuts.
- Raise and support the vehicle with jack stands.
- Remove the wheel and tire assembly.
- When dismounting the tire from the rim, note the following:
- Turn the wheel on tire mounting device so that valve/TPMS sensor is in front of mounting head.
- Position the tire changer mounting head near the tire valve so the tire iron can be placed approximately 30 degrees from the valve, Fig. . then remove the tire in ...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Volkswagen Beetle AUTOMOBILES
Alternator, Replace
Vehicle: 2007 Volkswagen Beetle 2.5 2.5 L5 GAS
- Disconnect battery ground cable.
- Remove engine cover.
- Raise and support vehicle.
- Release fasteners and remove lower noise insulation including drive belt cover.
- Remove front end:
- Remove headlamps.
- Remove wheelhousing liners.
- Remove bolts from wheelhousings and disconnect harness connectors for turn signals and fog lights.
- Disconnect hose connector in vehicles with headlight washer system.
- Remove attaching nuts, expanding clips, and bolts, then with aid of an assistant, pull left and right front end outward off threaded pins and remove forward from vehicle.
- Bring lock carrier into serv...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Volkswagen Beetle AUTOMOBILES
Cabin Air Filter Service -> Volkswagen -> 1998-2009 New Beetle
Vehicle: 2007 Volkswagen Beetle 2.5 2.5 L5 GAS
On 1998-2003 models, the cabin air filter should be replaced every 10,000 miles.
On 2004-06 models, the cabin air filter should be replaced every 24 months or 20,000 miles.
On 2007-08 models, the cabin air filter should be replaced every 24 months or 40,000 miles. The filter should be replaced more often if air flow is less than normal.
On 2009 models, the cabin air filter should be replaced every 24 months or 20,000 miles. The filter should be replaced more often if air flow is less than normal.
- Disconnect and isolate the battery ground cable.
- Push the instrument panel center c...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Volkswagen Beetle AUTOMOBILES
Volkswagen -> Malfunction Indicator Lamp -> -> Digifant & Digifant II -> Digifant I -> OBD ll
Vehicle: 2007 Volkswagen Beetle 2.5 2.5 L5 GAS
OBD ll
If faults are recognized and verified by the engine control module, they will be indicated by switching on the MIL. Perform the functional inspection as follows: Turn the ignition switch to the ON position. The MIL must light up if the MIL does not light with the ignition switch on, inspect the bulb and/or locate and eliminate short or open in wiring circuit from the engine control module to MIL using a proper wiring diagram. If no fault can be detected in the wiring the ECM may be faulty. If the MIL lights with the ignition switch on, start engine and run at idle speed the MIL must go o...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Volkswagen Beetle AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2007 Volkswagen Beetle 2.5 2.5 L5 GAS
Lower
- Drain coolant into a suitable container.
- Reposition hose clamp at radiator and remove hose.
- Reposition hose clamp at thermostat housing and remove hose.
- Remove hose from vehicle.
- Reverse procedure ...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Volkswagen Beetle AUTOMOBILES
Serpentine Drive Belt, Replace -> A/C Compressor Belt -> Alternator and Water Pump Belt
Vehicle: 2007 Volkswagen Beetle 2.5 2.5 L5 GAS
A/C Compressor Belt
- Remove right main headlamp assembly.
- Raise and support vehicle.
- Remove sound insulation.
- Remove right wheel and tire.
- Remove right front wheel housing liner.
- Mark direction of rotation of drive belt with chalk or felt pen if belt is to be reused.
- Rotate drive belt tensioner clockwise to release drive belt tension, using a suitable 15mm wrench.
- Secure tensioner, using a suitable locking tool.
- Remove A/C compressor drive belt.
- Reverse procedure to insta...
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Volkswagen Beetle AUTOMOBILES
Component location diagrams for most 2007 Volkswagen Beetle cars and light trucks sold in the U.S. from 1990+.
Fuel Components Diagram for 2007 Volkswagen Beetle 2.5 2.5 L5 GAS Components on diagram: |
Center Console Diagram for 2007 Volkswagen Beetle 2.5 2.5 L5 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Volkswagen Beetle AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Volkswagen Beetle cars and light trucks sold in the U.S.
2007 Volkswagen Beetle 2.5 2.5 L5 GAS Wiring Diagram Components on diagram: |
2007 Volkswagen Beetle 2.5 2.5 L5 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Volkswagen Beetle AUTOMOBILES
OEM TSB listings for most 2007 Volkswagen Beetle cars and light trucks sold in the U.S. from 1985+.
Document: Radio, Entering and Retrieving Anti-Theft (SAFE) Code Vehicle: 2007 Volkswagen Beetle 2.5 2.5 L5 GAS Auto Systems: |
Document: Radio Coding - Auxiliary Jack, iPod Inop After Radio Replacement Vehicle: 2007 Volkswagen Beetle 2.5 2.5 L5 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Volkswagen Beetle AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Volkswagen Beetle cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Volkswagen Beetle cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Volkswagen Beetle cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Volkswagen Beetle cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Volkswagen Beetle SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Volkswagen Beetle vehicle. |
Access the Complete guide! |