Auto Parts Search
2007 GMC Savana 1500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GMC REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Disc Brakes -> Delco Dual Piston Sliding Caliper -> Brake System Bleed -> Manual Bleed -> Pressure Bleed
Vehicle: 2007 GMC Savana 1500 5.3 V8 FLEX
Manual Bleed
- If vehicle is equipped with power brakes, remove vacuum reserve by applying brakes several times with engine off.
- Fill master cylinder reservoirs with suitable brake fluid. Ensure to always keep master cylinder reservoirs at least half full during entire bleeding procedure.
- If master cylinder is suspected to have air in bore, it must be bled first. To bleed master cylinder, proceed as follows:
- Disconnect forward brake pipe connection at master cylinder.
- Allow brake fluid to fill master cylinder bore until it begins to flow from forward pipe connector port.
- Connect and ...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
DRIVESHAFT, Replace -> Front -> One Piece Driveshaft -> Rear -> Two Piece Driveshaft
Vehicle: 2007 GMC Savana 1500 LT 5.3 V8 FLEX
Front
- Raise and support vehicle.
- Mark the front U-joint to the pinion yoke on the front differential.
- Mark the relationship of the rear U-joint to the transfer case drive flange.
- Remove the retaining nuts and bolts from the drive flange.
- Remove the clamps and retaining bolts from the front drive axle pinion flange.
- Remove the front propeller shaft from the vehicle.
- Using tape and or a rubber band, wrap the front U-joint bearing caps to ensure the caps do not separate from the U-joint.
- Reverse procedure to install, noting the following:
- Torque front propeller shaft retainer bolts 18 f...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Starter, Replace
Vehicle: 2007 GMC Savana 1500 LT 5.3 V8 FLEX
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove right transmission cover bolt, if required.
- Disconnect engine wiring harness electrical connector from oil level sensor.
- Remove starter motor mounting bolts.
- Slide starter forward until it clears transmission.
- Remove attaching nut and starter solenoid S-terminal lead from soleno...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
General Motors Corp./Saturn Trucks -> Traction Control System (TCS)/Electronic Stability Control (ESC) Warning Lamp ->
Vehicle: 2007 GMC Savana 1500 5.3 V8 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned On as a bulb check. If t...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2007 GMC Savana 1500 4.3 V6 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp from engine.
- Remove radiator outlet hose from engine.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator and from vehicle.
- Reverse procedure to install.
Uppe...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 GMC Savana 1500 5.3 V8 FLEX
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 GMC Savana 1500 AUTOMOBILES
Component location diagrams for most 2007 GMC Savana 1500 cars and light trucks sold in the U.S. from 1990+.
Door Components Diagram for 2007 GMC Savana 1500 LT 5.3 V8 GAS Components on diagram: |
Instrument Panel Diagram for 2007 GMC Savana 1500 LS 5.3 V8 FLEX Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 GMC Savana 1500 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 GMC Savana 1500 cars and light trucks sold in the U.S.
2007 GMC Savana 1500 5.3 V8 FLEX Wiring Diagram Components on diagram: |
2007 GMC Savana 1500 LS 5.3 V8 FLEX Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 GMC Savana 1500 AUTOMOBILES
OEM TSB listings for most 2007 GMC Savana 1500 cars and light trucks sold in the U.S. from 1985+.
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2007 GMC Savana 1500 4.3 V6 GAS Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2007 GMC Savana 1500 4.3 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 GMC Savana 1500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 GMC Savana 1500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 GMC Savana 1500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 GMC Savana 1500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 GMC Savana 1500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 GMC Savana 1500 vehicle. |
Access the Complete guide! |