Auto Parts Search
2007 Chrysler PT Cruiser CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chrysler REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Chrysler PT Cruiser AUTOMOBILES
Hydraulic Brake Systems -> Component Replacement -> Caravan & Town & Country -> Except Caravan & Town & Country -> Master Cylinder
Vehicle: 2007 Chrysler PT Cruiser Trouing 2.4 L4 GAS
Master Cylinder
Except Caravan & Town & Country
- With engine off, pump brake pedal five times to deplete vacuum in brake booster.
- Siphon fluid from brake reservoir.
- On Wrangler models, remove evaporative canister.
- On PT Cruiser models, remove air cleaner housing, then disconnect power distribution center and position aside.
- On all models, disconnect low fluid switch electrical connector.
- Remove brake lines from master cylinder.
- Remove master cylinder mounting nuts.
- On Durango models with ESP, remove inner fender well, then remove integrated power module (IPM) fasteners and move IPM ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Chrysler PT Cruiser AUTOMOBILES
CV AXLE SHAFT, Replace -> Install -> Remove
Vehicle: 2007 Chrysler PT Cruiser GT 2.4 L4 GAS
Remove
- Disconnect negative battery cable.
- Place transaxle in gated park.
- Raise vehicle on hoist.
- Remove wheel and tire assembly.
- Remove cotter pin, nut lock, spring washer and hub nut from end of outer C/V joint stub axle.
- On models equipped with ABS, disconnect front wheel speed sensor and secure harness out of the way.
- Remove nut and bolt retaining ball joint stud into steering knuckle.
- Separate ball joint stud from steering knuckle by prying down on lower control arm. Use caution when separating ball joint stud from steering knuckle, so ball joint seal does not get damaged.
- Rem...
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Chrysler PT Cruiser AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Trouble Code Identification -> Intermittent & Poor Connections -> Intermittents -> Low Pressure -> Poor Connections -> System Fault -> TPMS Check
Vehicle: 2007 Chrysler PT Cruiser GT 2.4 L4 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Trouble Code Identification
Refer to Fig. for diagnostic trouble code identification.
Clearing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector), and follow manufacturer's instructions.
TPMS Check
When diagnosing a TPMS problem, first check the TPMS indicator lamp with ignition switch in the On position. From the Off position, turn the ignition key to On and check the TPMS indicator la...
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Chrysler PT Cruiser AUTOMOBILES
Starter, Replace
Vehicle: 2007 Chrysler PT Cruiser GT 2.4 L4 GAS
- Unfasten clasps on sides of air cleaner housing cover and lift cover off air cleaner housing.
- Remove filter element.
- Disconnect battery ground cable.
- Raise and support vehicle.
- On models equipped with an automatic transaxle,remove bolts attaching bending strut to engine and transaxle.
- Remove bolts attaching structural collar to engine, oil pan, and transaxle then remove strut and structural collar.
- On models equipped with a manual transaxle,remove bolts attaching structural collar and clutch slave cylinder to transaxle.
- Remove remaining bolts attaching structural collar to oil pan and...
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Chrysler PT Cruiser AUTOMOBILES
Cabin Air Filter Service -> Chrysler LLC -> 2002-09 PT Cruiser
Vehicle: 2007 Chrysler PT Cruiser GT 2.4 L4 GAS
The cabin air filter should be replaced every 15,000 miles.
- Open the hood.
- Remove the passenger side cowl grille screen.
- Remove the three windshield washer reservoir to body attaching screws, then position the reservoir out of the way.
- Lift the cabin air filter eleme...
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Chrysler PT Cruiser AUTOMOBILES
Chrysler LLC Trucks -> Tire Pressure Monitoring System (TPMS) Warning Indicator -> 2007-09 PT Cruiser -> Relearn -> Reset
Vehicle: 2007 Chrysler PT Cruiser 2.4 L4 GAS
Reset
The Low Tire Pressure indicator lamp will flash slowly and sound a single tone when tire pressure is low. If tire pressure drops lower, the indicator lamp will flash rapidly and the tone will be continuous. When the tire is inflated to the proper pressure the lamp and tone will turn Off. The vehicle may need to be driven at a speed above 15 MPH for up to 10 minutes for the TPMS to receive this information. If the lamp remains On, a problem in the low tire warning system is present and the low tire warning system must be ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Chrysler PT Cruiser AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2007 Chrysler PT Cruiser Limited 2.4 L4 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater core inlet hose clamp at thermostat housing.
- Remove hose from thermostat housing.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Remove hose from vehicle.
- Reverse procedure to in...
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Chrysler PT Cruiser AUTOMOBILES
Serpentine Drive Belt, Replace -> Alternator Belt -> Power Steering Belt & A/C Compressor Belt
Vehicle: 2007 Chrysler PT Cruiser Limited 2.4 L4 GAS
Power Steering Belt & A/C Compressor Belt
- Remove right front splash shield.
- Release tension by rotating tensioner clockwise until belt can be removed from power steering pump pulley.
- Remove drive belt.
- Reverse procedur...
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Chrysler PT Cruiser AUTOMOBILES
Component location diagrams for most 2007 Chrysler PT Cruiser cars and light trucks sold in the U.S. from 1990+.
Rear Door Diagram for 2007 Chrysler PT Cruiser 2.4 L4 GAS Components on diagram: |
Left Rear Side Diagram for 2007 Chrysler PT Cruiser 2.4 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Chrysler PT Cruiser AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Chrysler PT Cruiser cars and light trucks sold in the U.S.
2007 Chrysler PT Cruiser Limited 2.4 L4 GAS Wiring Diagram Components on diagram: |
2007 Chrysler PT Cruiser Limited 2.4 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Chrysler PT Cruiser AUTOMOBILES
OEM TSB listings for most 2007 Chrysler PT Cruiser cars and light trucks sold in the U.S. from 1985+.
Document: Hard To Fill Or Fuel Nozzle Shuts Off Repeatedly Vehicle: 2007 Chrysler PT Cruiser 2.4 L4 GAS Auto Systems: |
Document: YES ESSENTIALS STAIN, ODOR, & STATIC RESISTANT FABRIC CARE - REVISED Vehicle: 2007 Chrysler PT Cruiser 2.4 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Chrysler PT Cruiser AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Chrysler PT Cruiser cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Chrysler PT Cruiser cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Chrysler PT Cruiser cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Chrysler PT Cruiser cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Chrysler PT Cruiser SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Chrysler PT Cruiser vehicle. |
Access the Complete guide! |