Auto Parts Search
2007 Chevrolet Suburban 1500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
Disc Brakes -> Delco Dual Piston Sliding Caliper -> Brake Pad Service
Vehicle: 2007 Chevrolet Suburban 1500 LS 5.3 V8 FLEX
The procedures to remove and install the brake pads are outlined i...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2007 Chevrolet Suburban 1500 LT 5.3 V8 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
Relearn Procedures
Vehicle: 2007 Chevrolet Suburban 1500 LT 6.0 V8 GAS
- Place the ignition switch in the Accy position.
- Press the keyless entry transmitters lock and unlock buttons at the same time until a horn chirp sounds or use the scan tool and select Special Functions/Sensor Learn Mode Enable/Enable soft key. A horn chirp will sound indicating the mode has been enabled.
- The horn should chirp twice and the low tire pressure warning indicator should begin to flash indicating the system is in the learn mode.
- Using GM tool No. J-46079 or equivalent, starting with the left front tire, hold...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
Starter, Replace
Vehicle: 2007 Chevrolet Suburban 1500 LS 5.3 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- On models equipped with skid plate, remove skid plate mounting bolts and skid plate.
- On all models, remove front transmission cover bolt.
- Remove transmission cover bolt.
- Remove starter motor mounting bolts.
- Disconnect engine wiring harness electrical connector from oil level sensor.
- Slide starter forward until it clears transmission, then properly support starter. Avoid cable and wiring damage. DO NOT suspend starter by cables or wires attached to solenoid terminals. Use a rope or mechanics wire to suspend starter.
- Lower vehi...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2007 Chevrolet Suburban 1500 LT 6.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
General Motors Corp./Saturn Trucks -> Reduce Engine Power Indicator Lamp ->
Vehicle: 2007 Chevrolet Suburban 1500 Z71 5.3 V8 FLEX
The Reduce Engine Power indicator lamp should light for a approximately 3 seconds when the ignition is turned On as a bulb check. If the warning lamp turns On during vehicle operation, a vehicl...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2007 Chevrolet Suburban 1500 LS 5.3 V8 GAS
Lower
- Drain cooling system into a suitable container.
- Remove air cleaner assembly.
- Reposition hose clamp from thermostat housing using hose clamp pliers J 38185 or equivalent.
- Remove radiator outlet hose from thermostat housing.
- Reposition hose clamp from radiator using hose clamp pliers J 38185 or equivalent.
- Remove rad...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Chevrolet Suburban 1500 LT 5.3 V8 FLEX
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
Component location diagrams for most 2007 Chevrolet Suburban 1500 cars and light trucks sold in the U.S. from 1990+.
Body Components Diagram for 2007 Chevrolet Suburban 1500 LT 5.3 V8 FLEX Components on diagram: |
Body Components Diagram for 2007 Chevrolet Suburban 1500 LTZ 5.3 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Chevrolet Suburban 1500 cars and light trucks sold in the U.S.
2007 Chevrolet Suburban 1500 LTZ 5.3 V8 GAS Wiring Diagram Components on diagram: |
2007 Chevrolet Suburban 1500 LT 6.0 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
OEM TSB listings for most 2007 Chevrolet Suburban 1500 cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2007 Chevrolet Suburban 1500 LS 5.3 V8 FLEX Auto Systems: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2007 Chevrolet Suburban 1500 LS 5.3 V8 FLEX Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Chevrolet Suburban 1500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Chevrolet Suburban 1500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Chevrolet Suburban 1500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Chevrolet Suburban 1500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Chevrolet Suburban 1500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Suburban 1500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Chevrolet Suburban 1500 vehicle. |
Access the Complete guide! |