Auto Parts Search
2007 Chevrolet Silverado CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Silverado AUTOMOBILES
Disc Brakes -> Delco Dual Piston Sliding Caliper -> Rotor, Replace
Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS
- Raise and support vehicle, then remove wheel and tire assemblies.
- Compress caliper pistons until they bottom in bores using suitable clamp.
- Remove calip...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Chevrolet Silverado AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Chevrolet Silverado AUTOMOBILES
Component Locations
Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS
Refer to Fig...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Chevrolet Silverado AUTOMOBILES
Alternator, Replace
Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS
- Disconnect battery ground cable.
- Disconnect positive crankcase ventilation hose from air cleaner outlet resonator.
- Loosen air cleaner outlet resonator clamps at mass air flow intake air temperature sensor and at throttle body.
- Remove air cleaner outlet resonator.
- Remove drive belt using suitable tools.
- Remove engine wiring harness clip from air conditioning compressor and condenser hose bracket.
- Remove air conditioning compressor and condenser hose bracket bolt.
- Remove heate...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Chevrolet Silverado AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Chevrolet Silverado AUTOMOBILES
General Motors Corp./Saturn Trucks -> Tire Pressure Monitoring System (TPMS) Warning Indicator -> 2007 Silverado -> Relearn -> Reset
Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS
Reset
When the TPMS detects a significant loss of tire pressure, the CHECK TIRE PRESSURE message is displayed on the DIC and the low tire pressure indicator is displayed on the IPC. Adjusting tire to recommended pressure will clear the tire message.
Relearn
- Place the ignition switch in the ACC position.
- Press the keyless entry transmitters lock and unlock buttons at the same time until a horn chirp sounds or use the scan tool and select Special Functions/Sensor Learn Mode Enable/Enable soft key. A horn chirp will sound indicating the mode has been enabled.
- The horn should chirp twice ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Chevrolet Silverado AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS
Inlet
- Drain cooling system into a suitable container.
- Remove air intake tube.
- Remove heater and surge tank hose from mounting clip.
- Release clamp on heater inlet hose at heater core.
- Remove hose from heater core.
- Release clamp on heater inlet hose at engine coolant outlet fitting.
- Remove hose from engine coolant outlet fitting.
- Remove hose from vehicle.
- ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Chevrolet Silverado AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS
- Remove air cleaner outlet duct.
- Rotate tensioner clockwise to release belt tension using breaker bar with hex-head socket, then remove drive belt.
- If replacing Air conditioner drive belt, rotate tensioner clockwise to release belt tension using breaker bar or ratchet, then remove belt.
- Clean and inspect belt su...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Chevrolet Silverado AUTOMOBILES
Component location diagrams for most 2007 Chevrolet Silverado cars and light trucks sold in the U.S. from 1990+.
Transmission Components Diagram for 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS Components on diagram: |
Engine Compartment Diagram for 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Chevrolet Silverado AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Chevrolet Silverado cars and light trucks sold in the U.S.
2007 Chevrolet Silverado Classic SS 6.0 V8 GAS Wiring Diagram Components on diagram: |
2007 Chevrolet Silverado Classic SS 6.0 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Chevrolet Silverado AUTOMOBILES
OEM TSB listings for most 2007 Chevrolet Silverado cars and light trucks sold in the U.S. from 1985+.
Document: Second Order Prop Shaft Vibration Or Launch Shudder Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS Symptoms: |
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2007 Chevrolet Silverado Classic SS 6.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Chevrolet Silverado AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Silverado SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Chevrolet Silverado vehicle. |
Access the Complete guide! |