Auto Parts Search
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2007 Chevrolet Aveo car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your 2007 Chevrolet Aveo automobile. Try the Automotix DIY solution today!
We have info for following modifications of 2007 Chevrolet Aveo
- 2007 Chevrolet Aveo Special Value 1.6 L4 GAS, CC:1598, CID:98, Fuel Injection, Aspiration:98, Engine VIN:, Desg:6
- 2007 Chevrolet Aveo LT 1.6 L4 GAS, CC:1598, CID:98, Fuel Injection, Aspiration:98, Engine VIN:, Desg:6
- 2007 Chevrolet Aveo LS 1.6 L4 GAS, CC:1598, CID:98, Fuel Injection, Aspiration:98, Engine VIN:, Desg:6
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Aveo AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Aveo cars and light trucks from 1990+.
Disc Brakes -> AC-Delco Single Piston Front Disc Brake -> Caliper Service -> Assemble -> Disassemble -> Inspection -> Replacement
Vehicle: 2007 Chevrolet Aveo LS 1.6 L4 GAS
Replacement
- Remove approximately 2/3 of brake fluid from master cylinder.
- Raise and support front of vehicle, then remove wheel and tire assembly.
- Push piston back into caliper bore using suitable C-clamp, Fig. .
- Remove inlet fitting mounting bolt, copper washer and inlet fitting from caliper housing. Plug opening in inlet fitting. Do not crimp brake hose.
- Remove caliper mounting bolts and caliper, Fig. . If there are signs of corrosion, replace bolts when installing caliper assembly.
- Reverse procedure to install.
Disassemble
- Clean outside of caliper, then drain brake fluid from caliper...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Aveo BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Aveo AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Aveo cars and light trucks from 1990+.
Drum Brakes -> Aveo -> Brake Service -> Installation -> Removal
Vehicle: 2007 Chevrolet Aveo LT 1.6 L4 GAS
Removal
- Raise and support vehicle, then remove tire and wheel assembly.
- Remove lock ring and caulking nut from spindle, then remove brake drum. If drum is difficult to remove, proceed as follows:
- Ensure parking brake is released.
- Back off parking brake cable adjustment.
- Loosen leading shoe hold down return spring.
- Disconnect upper link of connecting link spring on leading shoe to release tension on upper return spring.
- Remove upper return spring and adjuster.
- Disconnect trailing shoe and lining assembly hold down return spring, then the trailing shoe and lining assembly.
- Remove lower retur...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Aveo BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Aveo AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Aveo cars and light trucks from 1990+.
Power Brake Units -> Adjustments -> AC-Delco Tandem Diaphragm Type -> Air Method -> Brake Pedal -> Gauge Method -> Pushrod -> Toyota/GM Single Diaphragm Type
Vehicle: 2007 Chevrolet Aveo LT 1.6 L4 GAS
Brake Pedal
Toyota/GM Single Diaphragm Type
- With engine running and brake pedal in rest position, measure distance between face of pedal and floor mat.
- Distance should be 5.850-6.244 inches.
- If distance is not as specified, adjust pedal height as follows:
- Remove lefthand lower instrument panel trim section and air duct.
- Loosen stop lamp switch sufficiently to access pedal adjustment.
- Loosen locknut and rotate pedal pushrod as required to obtain specified pedal height. Tighten locknut.
- Adjust brake lamp switch position so plunger lightly contacts pedal stopper and brake lamps are off when pe...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Aveo BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Aveo AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Aveo cars and light trucks from 1990+.
Hydraulic Brake Systems -> Component Replacement -> Except ION & L-Series -> ION -> L-Series -> Master Cylinder
Vehicle: 2007 Chevrolet Aveo LS 1.6 L4 GAS
Master Cylinder
Except ION & L-Series
- On Vibe models, remove air filer hose clamp and hose from throttle body.
- On all models, disconnect fluid level sensor retainer and electrical connector.
- Drain master cylinder reservoir brake fluid into suitable container.
- Plug hose.
- Disconnect master cylinder brake pipes. Plug open pipes.
- Remove mounting nuts and master cylinder.
- Remove reservoir, as required.
- Reverse procedure to install. Bleed hydraulic system as outlined in .
ION
- Remove underhood electrical center cover.
- Remove Connector Position Assurance (CPA) connector from brake fluid level...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Aveo BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Aveo AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Aveo cars and light trucks from 1990+.
Disc Brakes -> AC-Delco Single Piston Front Disc Brake -> Rotor Replace
Vehicle: 2007 Chevrolet Aveo Special Value 1.6 L4 GAS
- Remove approximately 2/3 of brake fluid from master cylinder.
- Raise and support front of vehicle, then remove wheel and tire assembly.
- Push piston back into caliper bore using suitable C-clamp, Fig. .
- Do not disconnect brake line fitting from caliper.
- Remove mountin...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Aveo BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Aveo AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Aveo cars and light trucks from 1990+.
Anti-Lock Brakes -> Delphi MGH-25 -> Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Tests -> Diagnostic Trouble Code Interpretation -> EBCM Connector Views -> Electromagnetic Interference Test -> Intermittents & Poor Connections -> Preliminary Inspection
Vehicle: 2007 Chevrolet Aveo LS 1.6 L4 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to Data Link Connector (DLC) and follow manufacturer's instructions.
Preliminary Inspection
Before beginning service, perform the following preliminary inspection:
- Inspect master cylinder for proper brake fluid level.
- Inspect hydraulic modulator for any leaks or wiring damage.
- Inspect brakes at all four wheels to ensure no drag exists and that brakes are operating normally.
- Inspect wheel bearings for any excessive wear or damage.
- Inspect wheel speed sensors for correct air gap, solid sensor attachment, damage...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Aveo BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2007 Chevrolet Aveo vehicle.
|
| Access the Complete guide! |
